2014 Ford Mustang
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Mustang › 2014
These records cover every 2014 Ford Mustang. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2014 Ford Mustang. Newest first.
Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or…
Risk and remedy
Risk
In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Ford will notify dealers that purchased the affected parts, and dealers will provide replacement parts to purchasers, free of charge. The recall began March 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to…
Risk and remedy
Risk
In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is…
Risk and remedy
Risk
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.
Ford Motor Company (Ford) is recalling certain model year 2005-2014 Mustang vehicles manufactured April 6, 2004, to June 21, 2014, and 2005-2006 GT vehicles manufactured February 20, 2004, to September 22, 2006. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could…
Risk and remedy
Risk
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the front driver side air bag inflator, free of charge. The recall began on June 10, 2016. Even if interim repairs were performed under safety recall 14V-802, owners must bring their vehicles in for the final remedy. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S21. Note: This recall supersedes safety recall 14V-802.
Owner complaints
359 complaints30 involved a crash1 involved a fire23 injuries
What owners report most
Latest complaints
- Steering
The contact’s brother owns a 2014 Ford Mustang. While the owner was driving at an undisclosed speed, the vehicle drifted over to the left, crossed into the other lanes, drove into a ditch, and crashed into an object at the end of the ditch, causing the vehicle to become airborne. The vehicle landed…
The contact’s brother owns a 2014 Ford Mustang. While the owner was driving at an undisclosed speed, the vehicle drifted over to the left, crossed into the other lanes, drove into a ditch, and crashed into an object at the end of the ditch, causing the vehicle to become airborne. The vehicle landed in a nearby field and came to a complete stop. The contact stated that after several impacts, the air bags deployed. The contact stated that due to the impact, the driver was unable to state what had caused the vehicle to drift over to the left before crashing into the ditch. The driver received injuries to the lower body, L1 vertebrae, chest, and a fractured back. Medical attention was needed, and the driver remained in the Intensive Care Unit. A Police report was filed. The vehicle was towed to a tow yard and remained at the tow yard with extensive damage. The contact was informed that collision coverage was required to repair the vehicle. The contact was unsure if the vehicle was deemed a total loss. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
- Air bags
I am reporting a safety hazard and a failure by Ford Motor Company to properly remedy the mandatory Takata Airbag Recall. Following the recall repair, a technician reassembly error left the airbag warning light permanently illuminated, meaning my Supplemental Restraint System (SRS) is completely…
I am reporting a safety hazard and a failure by Ford Motor Company to properly remedy the mandatory Takata Airbag Recall. Following the recall repair, a technician reassembly error left the airbag warning light permanently illuminated, meaning my Supplemental Restraint System (SRS) is completely disabled and will not deploy in a crash. I took the vehicle to Astro Ford in Mississippi for resolution. The Service Manager, Hunter Landry, attempted to reset the system three times and confirmed a permanent safety fault exists in the exact recall area. However, Ford’s proprietary dealership software is actively blocking the dealer from pulling the diagnostic codes or proceeding with the repair without a corporate override code. Ford Corporate customer service agents have repeatedly refused to route this request or issue the override code to the dealer, effectively blocking the repair of a failed federal safety recall component. The dealer requires a corporate email sent to hunter.landry@astroford.com to authorize the diagnostic waiver and bypass the software block. Ford's corporate refusal forces me to drive an unsafe vehicle with no working airbags. Desired Resolution: I request that the NHTSA compel Ford Motor Company to immediately issue the corporate diagnostic override code to Hunter Landry at Astro Ford so this defective federal safety recall can be properly diagnosed and repaired at no cost to me.
- Power train
The contact owns a 2014 Ford Mustang. The contact stated that on several occasions while driving at various speeds, the transmission unexpectedly downshifted to a low gear. The check engine warning light illuminated and remained illuminated after the first failure. The vehicle was pulled over to…
The contact owns a 2014 Ford Mustang. The contact stated that on several occasions while driving at various speeds, the transmission unexpectedly downshifted to a low gear. The check engine warning light illuminated and remained illuminated after the first failure. The vehicle was pulled over to the side of the road, restarted, and the contact continued driving. The contact stated that during the last failure, while attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the residence, and a hand-held diagnostic machine retrieved DTC: P1500. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 138,000.
- Air bags
My son was driving to school. He was not speeding or any type of reckless driving. He hit an ice patch. His car spun and flew thru the air. The airbag compartment opened but it was defective. All metal shards came flying out of it causing multiple lacerations. He also lost consciousness from the impact and I was told by hospital ER doctor the airbag was defective and he was suffering from a very serious concussion.
- Vehicle speed control
The contact owns a 2014 Ford Mustang. The contact stated that while the vehicle was parked and occupied or while driving, the vehicle accelerated independently. A dealer was contacted. The vehicle was towed to the residence and then was towed the following day to a dealer to be diagnosed; however…
The contact owns a 2014 Ford Mustang. The contact stated that while the vehicle was parked and occupied or while driving, the vehicle accelerated independently. A dealer was contacted. The vehicle was towed to the residence and then was towed the following day to a dealer to be diagnosed; however, the contact was unaware of the diagnostic result. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 175,000.
- Steering
I was driving down the road and just lost power steering , a message came on and said loss of power steering assist , I pulled o er cut the car off waited a few min then started it back up and it was working again , then about 10 miles down the road it did it again
- Structure
The contact owns a 2014 Ford Mustang. The contact stated while the vehicle was parked and unoccupied, water leaked into the doors. The contact stated that a dealer was contacted. The contact stated that while it was snowing the water in the door would freeze. The vehicle was taken to the dealer to…
The contact owns a 2014 Ford Mustang. The contact stated while the vehicle was parked and unoccupied, water leaked into the doors. The contact stated that a dealer was contacted. The contact stated that while it was snowing the water in the door would freeze. The vehicle was taken to the dealer to be diagnosed; however, the contact refused to leave the vehicle at the dealer, and the contact declined to pay for a diagnostic test. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 129,983.
- Power train
The contact owns a 2014 Ford Mustang. The contact stated while driving at 65 MPH, the transmission unexpectedly downshifted to first gear. The check engine warning light illuminated, and the instrument cluster was red. The vehicle was taken to an independent mechanic where it was diagnosed with a…
The contact owns a 2014 Ford Mustang. The contact stated while driving at 65 MPH, the transmission unexpectedly downshifted to first gear. The check engine warning light illuminated, and the instrument cluster was red. The vehicle was taken to an independent mechanic where it was diagnosed with a failed transmission ring sensor. The contact was informed that the transmission ring sensor needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the failure was intermittent, and occasionally the vehicle lost motive power. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 172,000.
- Electrical system · Steering
Power steering assist stopped working, shutting my traction and advanced traction control off
- Power train · Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Wheel speed sensor/tone ring
The contact owns a 2014 Ford Mustang. The contact stated that while driving approximately 80 MPH, the transmission unexpectedly downshifted from fifth gear to first gear, causing the vehicle to abruptly decelerate. After turning off and restarting the vehicle, the vehicle operated but in LIMP Mode.…
The contact owns a 2014 Ford Mustang. The contact stated that while driving approximately 80 MPH, the transmission unexpectedly downshifted from fifth gear to first gear, causing the vehicle to abruptly decelerate. After turning off and restarting the vehicle, the vehicle operated but in LIMP Mode. The vehicle was taken to the local service center who diagnosed that the wheel speed sensor and lead frame needed to be replaced. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 140,000.
- Air bags
The contact owns a 2014 Ford Mustang. The contact received notifications of NHTSA Campaign Numbers: 15V319000 (Air Bags) and 19V001000 (Air Bags); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time…
The contact owns a 2014 Ford Mustang. The contact received notifications of NHTSA Campaign Numbers: 15V319000 (Air Bags) and 19V001000 (Air Bags); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
- Air bags
The contact owned a 2014 Ford Mustang. The contact stated while driving at 45 MPH, the contact fell asleep and lost control of the vehicle, causing the vehicle to crash into the rear end of another vehicle. The air bags failed to deploy, causing the contact to hit his head against the steering…
The contact owned a 2014 Ford Mustang. The contact stated while driving at 45 MPH, the contact fell asleep and lost control of the vehicle, causing the vehicle to crash into the rear end of another vehicle. The air bags failed to deploy, causing the contact to hit his head against the steering wheel. The contact became dizzy and lightheaded. The contact was able to exit the vehicle; however, the front driver's side door could only slightly open due to the significant damage to the vehicle's front end. The contact received medical assistance the following day. The contact underwent a CT scan and was informed that he had sustained a concussion. The vehicle was towed and totaled. A police report was filed. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,502.
- Air bags
The contact owns a 2014 Ford Mustang. The contact received notification of NHTSA Campaign Number: 15V319000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer…
The contact owns a 2014 Ford Mustang. The contact received notification of NHTSA Campaign Number: 15V319000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
- Engine · Fuel/propulsion system · Power train
the following problem happened to me a few years ago (twice within a couple of months) and again, 2 days ago. Each time I was standing at a traffic light when all of a sudden it accelerated at full throttle. I practically stood on the brake pedal, but the car was inching forward, as I put the…
the following problem happened to me a few years ago (twice within a couple of months) and again, 2 days ago. Each time I was standing at a traffic light when all of a sudden it accelerated at full throttle. I practically stood on the brake pedal, but the car was inching forward, as I put the transmission into park. This was not a subtle situation, it was dangerous. The engine went from idle to screaming within 2 seconds. I ruled out the floor mat as it was in the proper position and snapped into the floor. It did not cause any warning lights to come on. in May, I had the oil changed, at which time they suggested that they clean the throttle body, which they did.They never heard of the above problem.
- Power train
Was driving my vehicle on the freeway traveling about 70 miles per hour when the vehicle suddenly shifted into first gear. I was able to maintain control and the vehicle shifted back to sixth gear. Issue occurred again within 5 minutes of the first incident and then the vehicle went into "Limp…
Was driving my vehicle on the freeway traveling about 70 miles per hour when the vehicle suddenly shifted into first gear. I was able to maintain control and the vehicle shifted back to sixth gear. Issue occurred again within 5 minutes of the first incident and then the vehicle went into "Limp Mode". I was able to drive the vehicle home under this condition. Vehicle check engine light turned on and the code P0720, which is the Output Speed Sensor Circuit. This is the same issue that occurred on 2011-2013 F-150 and Mustang vehicles that currently have a recall for this (Safety Recall 19S07). The same transmissions (6R80) are used in both vehicles, as well as the Powertrain Control Modules, but my vehicle's VIN did not fall under this recall. This is a very dangerous issue that could lead to a deadly accident.
- Engine · Fuel system, gasoline · Power train
The contact owns a 2014 Ford Mustang. The contact stated that while driving approximately 35-70 MPH, the vehicle inadvertently downshifted to first gear. The contact stated that the rear wheels locked up and the vehicle jolted forward. The air bag, fuel, and check engine warning lights were…
The contact owns a 2014 Ford Mustang. The contact stated that while driving approximately 35-70 MPH, the vehicle inadvertently downshifted to first gear. The contact stated that the rear wheels locked up and the vehicle jolted forward. The air bag, fuel, and check engine warning lights were illuminated. The vehicle was towed to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 80,000.
- Power train
On 5-26-22 i took my mustang to Roush Ford in Hillard Oh. They tested and found out that I needed a lead frame connector. Part # Al327627V $ 226.10. I paid in advance for this part as Roush said they would not order unless I paid in advance. Roush stated they would call when part comes in. I made…
On 5-26-22 i took my mustang to Roush Ford in Hillard Oh. They tested and found out that I needed a lead frame connector. Part # Al327627V $ 226.10. I paid in advance for this part as Roush said they would not order unless I paid in advance. Roush stated they would call when part comes in. I made several attempts to get status of part and all they would say is they were still awaiting. On or about 6-20-23 I called again, At this time they stated the dealership had been sold to Valley ford and still no word on part arrival. I have owned several Fords in my life but after awaiting over 1 yr on a part and car I could not safely have my wife drive I decided to trade it in for another vehicle. I then called Valley to ask for them to credit my card in the amount of the part. They told me that the money went with Roush and they could not return my money?? They suggested I call Roush auto group( Honda ). I made the call to service manager and he said that Roush Ford was no longer in business and they could not refund my monies. In my mind Ford was paid the $226.10 and someone should be able to pay me back. I am asking that The Ford Motor co honor the deal by paying me back. Thanks
- Structure › Body · Unknown or other
My clutch pedal went out before a moth of ower ship, my transmission 3rd gear went out before a month of owner ship, my bumper second time flying off on me 2nd month of owner ship.
- Power train
While driving the clutch pedal will stick to the floor after shifting gears. You can pull the pedal up manually and it will functioning properly for a while but will repeat sticking to the floor. May happen once a day, once a week or more often. Ambient temperature has no affect to the problem. Car currently has 15,000 miles on it
- Service brakes
I currently own a 2014 Mustang GT with a manual transmission and notice my emergency brake release button was cracking. The button is made of cheap plastic and the dealer does not have a replacement release button. They only sell the whole emergency brake, which I feel that Ford should she be…
I currently own a 2014 Mustang GT with a manual transmission and notice my emergency brake release button was cracking. The button is made of cheap plastic and the dealer does not have a replacement release button. They only sell the whole emergency brake, which I feel that Ford should she be responsible of replacing the emergency brake button, since this is a safety issue that you cannot engage the emergency brake or disengage the emergency brake button when parking your vehicle on a hilly driveway or any hill at all. Which I leave in Northern California that is very hill and feel that if my car ever comes disengaged out of 1st gear it would cause serious damages to others, such as crashing into a building or other cars or even a fatality.
- Air bags
I randomly checked to see if any recalls were out regarding this vehicle. Upon checking I entered my vin # but was advised it was not part of the airbag recall. However my airbag light constantly comes on.
- Service brakes · Unknown or other
2014 FORD MUSTANG Experiencing exact same issues as when car is parked and shifting into the gear intended by the driver. That could cause the vehicle to roll away or move in an "unexpected direction". This is the same issue as the recall issued for other Ford vehicles: (but 2014 Ford Mustang is…
2014 FORD MUSTANG Experiencing exact same issues as when car is parked and shifting into the gear intended by the driver. That could cause the vehicle to roll away or move in an "unexpected direction". This is the same issue as the recall issued for other Ford vehicles: (but 2014 Ford Mustang is not listed) 2013-2019 Escape 2013-2018 C-Max 2013-2016 Fusion 2013-2021 Transit Connect 2015-2018 Edge "A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction," the National Highway Traffic Safety Administration (NHTSA) said in a statement. "Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury." My daughter had several near missed with this safety issue - and when I asked for diagnostics the dealer wanted to charge $ 139.99 plus taxes. The recall needs to be issue to include : 2014 FORD MUSTANG
- Engine · Service brakes · Steering
I was going up a steep driveway. I made it to the top, then needed to get back down. I put my car in reverse and proceeded to back down the driveway. Suddenly and without warning, my brakes and steering went out. The whole car shut off and the battery light turned on. Not being able to brake or steer, my car rolled down the driveway into a fence before coming to a stop. This caused extensive damage to my vehicle.
- Power train
The 6 speed manual transmission grinds and/or locks out of gear when shifting from 1ST to 2ND gear. The car bucks and surges, worse when going downhill. It makes a knocking noise when there IS a torque change.
- Back over prevention
The contact owns a 2014 Ford Mustang. The contact stated that while reversing, the rearview camera turned blank. The contact also stated that while driving at 15-20 MPH, the beeping sound that the vehicle made while reversing activated independently. There were no warning lights illuminated. The…
The contact owns a 2014 Ford Mustang. The contact stated that while reversing, the rearview camera turned blank. The contact also stated that while driving at 15-20 MPH, the beeping sound that the vehicle made while reversing activated independently. There were no warning lights illuminated. The contact became aware of NHTSA Campaign Number: 22V082000 (Back Over Prevention) and contacted the dealer. The dealer informed the contact that his vehicle could not be repaired under the recall as his VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to NHTSA for assistance with including his VIN in the recall for NHTSA Campaign Number: 22V082000 (Back Over Prevention). The failure mileage was approximately 67,000.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008948While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
- 10254138All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
- 10251951Some 2011-2024 Mustang and F-150 vehicles equipped with a 5.0L engine may exhibit a tick tap and/or typewriter ticking noise at idle after an engine oil change. It is often referred to as typewriter noise because of its similarity to the sound of a mechanical typewriter. The noise in question may be heard on some engines when engine temperatures reach 150F (65C) or higher and engine speed is at idle up to approximately 1700 RPM. It can typically be heard at the front wheel well and is often isolated to the transmission bell housing or oil pan area. The typewriter noise tick rate can be faster or slower and is not detrimental to the engine function or durability and has no short or long term effects on the engine. This an operating characteristic of the 5.0L engine and no repairs should be attempted. This information along with an example audio clip has been added to the WSM Section 303-00 Engine System General Information > Diagnosis and Testing > Engine > PPT F > Step F2.
- 10235153For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
- 10212957Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle commands such as door lock/unlock, remote start, vehicle location, etc. The battery drain may be caused by excessive calls for data through the vehicle network keeping it in an activated state. Recommend that the customer uninstall the app to ensure this is not contributing to battery symptoms experienced. Advise the customer that unaffiliated third-party app developers do not work directly with Ford to adhere to security, vehicle communication, and privacy requirements.
- 10209374Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion & MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection: Ford Motor Company has determined that some vehicles claimed by dealers as repaired under Takata Airbag Safety Recalls 15S21, 17S42, 18S02, 19S01, and 21S12 may not have received the claimed repairs. The propellant in certain Takata airbag inflators can experience an alteration over time with exposure to certain climate conditions. A combination of time, high temperature fluctuations, and humidity contribute to the degradation of the propellant in the inflators. This degradation can cause the propellant to burn too quickly, creating high pressure inside the inflator, and in extreme cases causing the inflator to rupture in the event of a crash necessitating airbag deployment. A ruptured inflator can send inflator parts toward vehicle occupants resulting in serious injury or death. Additional information regarding Takata recalls can be found at www.nhtsa.gov and www.safercar.gov.
- 102050393.7L Engine - Cfoolant pump leak
- 10205031Touchscreen navigation system - arabic language - blank screen
- 1020498749 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
- 1020498649 CFR Part 579.5 Monthly Communications - January 2016
- 10191525Some 2011-2021 Mustang and F-150 vehicles equipped with a 5.0L engine may exhibit a ticking noise at idle after an engine oil change. It is often referred to as typewriter noise because of its similarity to the sound of a mechanical typewriter. The noise in question may be heard on some engines when engine temperatures reach 150F (65C) or higher and engine speed is at idle up to approximately 1700 RPMs. It can typically be heard at the front wheel well and is often isolated to the transmission bell housing or oil pan area. The typewriter noise is not detrimental to the engine function or durability and has no short or long term effects on the engine. This an operating characteristic of the 5.0L engine and no repairs should be attempted.
- 10183775Some 2011-2014 Mustang vehicles equipped with a 3.7L engine may exhibit coolant pump leakage due to air entering the system.
- 10183767Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.
- 10183567For 2011-2020 F-150/Mustang vehicles equipped with a 5.0L engine when installing a replacement secondary timing chain tensioner (6K254) or secondary timing chain guide (6K297), it is necessary to replace both components as a pair, using the latest level parts. Make sure to use secondary timing chain tensioner part number ML3Z-6K254-A and secondary timing chain guide part number ML3Z-6K297-A.
- 10177863This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
- 10172972SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active and the original keys cannot be accessed to disable the perimeter alarm. This concern would most often occur when a customer loses keys and the dealership is attempting to program new keys to the vehicle. The Workshop Manual (WSM), Section 419-01A Perimeter Anti-Theft Alarm - System Operation and Component Description has been updated to inform of the Controller Area Network (CAN) Protection Strategy. Follow the procedure outlined to prevent replacement of the Body Control Module (BCM) on CAN Protection Strategy equipped vehicles when original keys are lost and perimeter alarm is active. Refer to the WSM for further detail on the CAN Protection Strategy. Lost keys and replacement of BCM for lost keys is non-warrantable.
- 10164497For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable clamp and clean the cable end as necessary to preserve wire length. Some rework may be necessary for some vehicle environments. Bend the new positive battery cable clamp as needed and crimp it to the existing battery cable. Make sure to use heat shrink tubing over the battery cable to battery cable clamp connection. Obtain the heat shrink tube locally.
- 10163573Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Use pigtail harness service part numbers 3U2Z-14S411-ZEA or CU2Z-14S411-FA, as both parts are interchangeable. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures.
- 10160931On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.
- 10159489Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S. dealership free of charge with shipments completed 19-Apr-2019 (reference EFC07013 on FMCDealer.com). This tester will help reduce the potential for misdiagnosis and unnecessary compressor replacement. Make sure that this tester is used for warranty repairs and document the test results in the Technician Comments field. Refer to the Rotunda catalog for a video and user manual which provide detailed operating instructions.
- 10156888Some 5.0L 4V engines may exhibit a tick/tap/rattle or knock immediately after secondary timing chain tensioner installation. In some cases the secondary timing chain tensioners are not fully released during installation.To confirm, remove both valve covers and inspect the secondary timing chains and tensioners. If the chain is loose fitting and the tensioner does not appear to be extended, using your hand depress the chain/guide and tensioner several times or until the tensioner releases taking up the slack in the chain. If the chain does not have slack, follow Workshop Manual Section 303-00 to diagnose. The Workshop Manual section 303-01C has been updated to reflect the installation releasing process for the secondary timing chain tensioner.
- 10156877Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures. Refer to Wiring Diagram, Cells 54/55 to obtain the service pigtail connector part number.
- 10156863Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
- 10155576Some 5.0L 4V engines may exhibit a tick/tap/rattle or knock immediately after secondary timing chain tensioner installation. In some cases the secondary timing chain tensioners are not fully released during installation.To confirm, remove both valve covers and inspect the secondary timing chains and tensioners. If the chain is loose fitting and the tensioner does not appear to be extended, using your hand depress the chain/guide and tensioner several times or until the tensioner releases taking up the slack in the chain. If the chain does not have slack, follow Workshop Manual Section 303-00 to diagnose. The Workshop Manual section 303-01C has been updated to reflect the installation releasing process for the secondary timing chain tensioner.
- 10155565Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures. Refer to Wiring Diagram, Cells 54/55 to obtain the service pigtail connector part number.
- 10155551Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
- 10153969Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
- 10148735Some 2011 - 2014 Mustang vehicles equipped with a 3.7L V6 engine and MT82 manual transmission may exhibit a vibration felt in the shifter, and/or the seat track and steering wheel, on deceleration between 3500 and 2000 engine RPM. This an operating characteristic of the vehicle and no repairs should be attempted.
- 10140323The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.
- 10138524The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.
- 10137113Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems. If you suspect a system has been modified, the following resources can be used to verify original equipment: Monroney Label (Window Sticker), Professional Technician Society (PTS) OASIS tab select SYNC or HVBOM. For Genuine Ford accessories use: PTS Workshop Tab select Dealer Installed Accessory or Accessory Installation.
- 101365972010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
- 10127405Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the on-screen instructions to complete the procedure. This procedure will transfer the existing Key ID information between the modules without the need of having 2 programmed PATS keys present. There is no need to program keys when the PCM is going to be replaced. Additional information can be found in the Workshop Manual (WSM), Section 419-01. Missing or lost keys are not warrantable.
- 10109070The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
- 100994632009-2017 vehicles equipped with a 6R80, 6r100, 6r140 automatic transmission have an updated main control valve body overhaul procedure. Refer to workshop manual (wsm), section 307-01 for main control valve body (7a100) overhaul procedures. Not all valve bodies require replacement. Inspect the valve body bores, springs and valves as directed during diagnosis and repair. Refer to general service bulletin (gsb) g0000093 automatic transmission main control inspection for a video clip to aid in the diagnosis of these repairs.
- 10095995Some 2010-2016 epas equipped vehicles may exhibit steering related noises. The workshop manual (wsm) diagnostic procedures have been updated in section 211-02. When diagnosing and repairing epas steering noises use the updated procedures.
- 10095184Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features IS not recommended nor supported on any ford, mercury or lincoln vehicle. Only approved genuine ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems. If you suspect a system has been modified, the following resources can be used to verify original equipment: monroney label (window sticker), professional technician society (pts) oasis tab select sync or hvbom. For genuine ford accessories use: pts workshop tab select dealer installed accessory or accessory installation.
- 10095154To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye IS available. Workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. The new white fluorescent dye provides a distinct white glow to identify engine oil leaks. The new white fluorescent dye requires a pure uv diagnostic inspection lamp. The white-colored fluorescent dye and pure uv lamp are now in the rotunda catalog. Dye and lamp part numbers. Gasoline only dye: 1 ounce bottle 164-tp-33200601. Diesel only dye: 8 ounce bottle: 164-tp-3320-0008. Pure uv diagnostic inspection lamp 164-tp8695 or 164-r3748.
- 10091151Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service IS required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps illuminated in the instrument cluster. Rerun the vhr with the engine on and vehicle in park, and ensure the park brake IS disengaged. If the sync vhr IS still reporting a concern to the customers sync owners account, refer to the appropriate workshop manual section for diagnosis by dtc or symptom. Starting in 2015 not all sync equipped vehicles support vhr, refer to the owners manual for vhr operation.
- 10090681Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service IS required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps illuminated in the instrument cluster. Rerun the vhr with the engine on and vehicle in park, and ensure the park brake IS disengaged. If the sync vhr IS still reporting a concern to the customers sync owners account, refer to the appropriate workshop manual section for diagnosis by dtc or symptom. Starting in 2015 not all sync equipped vehicles support vhr, refer to the owners manual for vhr operation.
Every Ford Mustang model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.