2004 Nissan Titan
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Nissan › Titan › 2004
These records cover every 2004 Nissan Titan. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2004 Nissan Titan. Newest first.
Nissan IS recalling certain model year 2004-2006 armada, titan, infiniti QX56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. The ecm relay may allow silicon vapor to form and…
Risk and remedy
Risk
This could cause engine stalling increasing the risk of a crash.
Remedy
Dealers will replace the ecm relay inside the ipdm assembly. This service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Nissan IS recalling certain front and rear lower links, p/nos. 54501Zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and QX56, and model years 2005 through 2010 frontier…
Risk and remedy
Risk
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Remedy
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an…
Risk and remedy
Risk
This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
Remedy
Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
On certain crew cab model trucks, the seat back shape may be such that there may not be sufficient webbing on the retractor spool for the rear center seat belt to release from the automatic locking mode (alr) after it IS engaged and the seat belt IS retracted. if this occurs, there may be difficulty in pulling the seat belt out of the retractor thus…
Risk and remedy
Risk
In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury.
Remedy
Dealers will replace the rear center seat belt with a new one free of charge. the recall began on june 11, 2007. owners may contact nissan at 1-800-647-7261.
On certain king cab trucks, the wires in the harness were routed through the rear doors and into the body. these wires may break due to over bending of the harness as the door IS opened and closed. the harness contains wires for the driver seat belt pretensioner and for the front passenger seat belt which IS part of the occupant classification system.…
Risk and remedy
Risk
If the wires for the seat belts and speaker wires break and make contact, there IS a possibility that the pretensioner may deploy. if this happens when the seat belt IS retracted, it will not be possible to use the seat belt. if one of the wires on the right side harness for the seat belt tension sensor breaks, the passenger side front air bag will not deploy as designed in a frontal collision increasing the risk of a crash and personal injury.
Remedy
Dealers will replace the wire harness cover with a different type that prevents over bending of the harness and the harness will be rerouted free of charge. the recall began on february 19, 2007. owners may contact nissan at 1-800-647-7261.
On certain pickup trucks equipped with a column shifter, the shift lever assembly for the column shifter may have been damaged during assembly.
Risk and remedy
Risk
During its use this could eventually result in failure of the portion of the assembly that holds the lever in the park position. this could result in a crash.
Remedy
Dealers will inspect and replace the shifter. the recall began on september 27, 2004. owners should contact nissan at 1-800-647-7261.
Certain pickup trucks fail to comply with the requirements of federal motor vehicle safety standard no. 201, "occupant protection in interior impact." an area on the rear pillar where the rear seat belt upper anchor IS attached may not be sufficiently energy absorbent.
Risk and remedy
Risk
This could result in an increased risk of injury if the area IS struck in a crash.
Remedy
Dealers will replace the outboard rear seat belt assemblies with new ones. the recall began on september 27, 2004. owners should contact nissan at 1-800-647-7261.
Owner complaints
1,046 complaints28 involved a crash12 involved a fire19 injuries6 deaths
What owners report most
Latest complaints
- Service brakes
Brakes - sitting at the used car dealership since 8.8.2025. The truck will not stop when the brakes are applied. If the vehicle does not stop when brakes are applied. Lives are at risk if they are hit or ran over. Inspected by a Nissan dealership, invoices are available. The Brake Booster is no…
Brakes - sitting at the used car dealership since 8.8.2025. The truck will not stop when the brakes are applied. If the vehicle does not stop when brakes are applied. Lives are at risk if they are hit or ran over. Inspected by a Nissan dealership, invoices are available. The Brake Booster is no longer manufactured by Nissan. No repair is available. Unknown. No accidents have occurred due to this, we are in fear of our safety to drive it. The Sales manager at the dealership disconnected the ABS. We purchased this vehicle on 6.23.2025. The Brakes were not working within driving this vehicle for less than 3 weeks. We have made a formal complaint to the dealership. Taken it to a certified Nissan Dealer. The dealership we purchased this truck from has ignored every request we have made. We hired an attorney here in St. George, UT. The dealership has not replied to our Attorney. This Vehicle is NOT SAFE to be driven on the roads. We would like to know what the safety measures are in place for a USED vehicle dealership to sell an AS-IS-VEHICLE. Please see that I have attached all of our documentation we have provided to the State of Utah, our Attorney and to the Motor Vehicle Division of the State of Utah. A persons safety in their vehicle is a must.
- Air bags
Vehicle was purchased and air bag light was on. Dealership did not disclose any safety issues. When brought to my mechanic found broken wiring in airbag harness and driver's side airbag was not functioning and risk of deployment at any time. Also open recall on driver's side airbag
- Air bags
Airbag warning light is blinking.
- Service brakes, hydraulic
The contact owns a 2004 Nissan Titan. The contact stated that while driving 5-10 MPH, the brake pedal was depressed and pulsated. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 166,000.
- Unknown or other
There have been many complaints about the rear end of this truck and it says they been waiting for a recall for 6 years over the rear end of this truck and mine went out wile on the high way at high speed I defnatly feel my life was in danger and many others also how do I get this handled I need my…
There have been many complaints about the rear end of this truck and it says they been waiting for a recall for 6 years over the rear end of this truck and mine went out wile on the high way at high speed I defnatly feel my life was in danger and many others also how do I get this handled I need my rear end fixed I can not go to work I am fixing to be homeless over this issue and it could have ended with me loiseing my life
- Air bags
The contact owns a 2004 Nissan Titan. The contact stated that after receiving the vehicle from the dealer following a recall repair, the air bag warning light illuminated on the instrument panel. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After…
The contact owns a 2004 Nissan Titan. The contact stated that after receiving the vehicle from the dealer following a recall repair, the air bag warning light illuminated on the instrument panel. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23E012000 (Air Bags) and the VIN was included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 21,000.
- Electrical system · Service brakes
The contact owns a 2004 Nissan Titan. The contact stated while driving approximately 35 MPH and descending a hill, the brake pedal was depressed and went to the floor. The contact stated that she pumped the brake pedal, but the vehicle failed to respond immediately. The contact then used the gear…
The contact owns a 2004 Nissan Titan. The contact stated while driving approximately 35 MPH and descending a hill, the brake pedal was depressed and went to the floor. The contact stated that she pumped the brake pedal, but the vehicle failed to respond immediately. The contact then used the gear lever to shift to neutral(N) and then to park(P) and the vehicle stopped. The contact then turned the vehicle off. The contact stated that prior to the brake failure the instrument panel lights had started to flash on and off. The contact restarted the vehicle, and the brake functionality returned. The contact stated that the failure was intermittent but had gradually become more frequent. The contact stated that the brake failure and instrument panel lights malfunction occurred three times in one day. The contact had been unable to schedule an appointment with a dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was 88,290.
- Service brakes, hydraulic
The contact owns a 2004 Nissan Titan. The contact stated that while driving at 20 MPH, the brakes seized, causing the vehicle to rear-end another vehicle. The B-LSD and ABS warning lights were illuminated. No air bags were deployed. The contact did not sustain any injury, and medical attention was…
The contact owns a 2004 Nissan Titan. The contact stated that while driving at 20 MPH, the brakes seized, causing the vehicle to rear-end another vehicle. The B-LSD and ABS warning lights were illuminated. No air bags were deployed. The contact did not sustain any injury, and medical attention was not received. Two passengers in the other vehicle later sustained bodily injuries. A police report was filed. The vehicles involved in the collision were able to drive away from the scene. The vehicle was taken to the dealer, where it was diagnosed that the incorrect ABS module was installed and that the ABS module needed to be replaced. The vehicle was not repaired. The contact related the failure to the delta stroke sensor malfunctioning. The manufacturer was made aware of the failure. The failure mileage was approximately 226,000.
- Power train
The contact owns a 2004 Nissan Titan. The contact stated that while the vehicle was parked, the vehicle rolled forward, causing the vehicle to roll into a rock, and damaging the transmission. Additionally, the air bag warning lights illuminated, and the seat beats locked. The vehicle was towed to the residence. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 180,000.
- Fuel/propulsion system
I was driving down a main road by my office, accelerating when the car suddenly stalled. As the truck was independently decelerating, the steering wheel became hard to steer due to the truck being "off". I managed to force it to turn to a shoulder so as to not get rear ended by vehicles behind me.…
I was driving down a main road by my office, accelerating when the car suddenly stalled. As the truck was independently decelerating, the steering wheel became hard to steer due to the truck being "off". I managed to force it to turn to a shoulder so as to not get rear ended by vehicles behind me. I could've been on the highway with traffic speeds up to 70mph and it would've been a different scenario. I later found out that the 1/4 fuel on the gauge was faulty and I was out of gas. I went to the NHTSA website to find out 2005 model Titans were included in the recall but not my 2004.
- Power train
Purchased a used 2004 Nissan titan truck with lower miles. Rear axel exploded and burst into flames when driving down the freeway. (Bowling Green, Kentucky) We managed to pull off to the side of the freeway without hitting anyone. Fire dept was able to put the flames out. Didn't find any recalls…
Purchased a used 2004 Nissan titan truck with lower miles. Rear axel exploded and burst into flames when driving down the freeway. (Bowling Green, Kentucky) We managed to pull off to the side of the freeway without hitting anyone. Fire dept was able to put the flames out. Didn't find any recalls about the Truck when we bought it. Now I have seen reports on line that this has happened to other consumers. Something needs to be done to warn consumers. We could have died. We could of hit others and killed them as well. Dealership has completed repairs and seen the defect. We have the damaged part. There were no prior warnings. Vehicle was inspected before the road trip to insure it was safe.
- Unknown or other
When I drive my truck under rain or wet road I have several incidents if my truck tires slip the truck goes out of control if I keep pressing the pedal. Is scary feeling specially because losing control under rain is to unsafe. I know it that on my dashboard the airbags warning is blinking is that…
When I drive my truck under rain or wet road I have several incidents if my truck tires slip the truck goes out of control if I keep pressing the pedal. Is scary feeling specially because losing control under rain is to unsafe. I know it that on my dashboard the airbags warning is blinking is that has something to do with my incidents ? Can you guys fix this problem thank you. Is raining season and I don't want to suffer injuries or death
- Engine
The contact owns a 2004 Nissan Titan. The contact stated while driving at various speeds, the vehicle would suddenly stall with the check engine warning light illuminated. The vehicle was towed to the local dealer who could not determine the cause of the failure. The contact performed a diagnostic…
The contact owns a 2004 Nissan Titan. The contact stated while driving at various speeds, the vehicle would suddenly stall with the check engine warning light illuminated. The vehicle was towed to the local dealer who could not determine the cause of the failure. The contact performed a diagnostic test and determined that the engine control module was faulty and needed to be replaced. The vehicle was not yet repaired. The contact was informed that the vehicle was included in NHTSA Campaign Number: 10V517000 (Engine). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 255,000.
- Engine · Unknown or other
My Titan is a 4 door not 2, also I am not sure if these recalls I saw are related to the problems I am having but my light indicator (as in the pictures I provided) has come on twice I immediately turn it off and I wait for the engine to cool it gets really hot but it doesn't indicate any over…
My Titan is a 4 door not 2, also I am not sure if these recalls I saw are related to the problems I am having but my light indicator (as in the pictures I provided) has come on twice I immediately turn it off and I wait for the engine to cool it gets really hot but it doesn't indicate any over heating on the dash indicators (it might just be me but it seems hot enough to be overheating) and once cooled i check the fluids and refill the oil as needed (coolant level been fine) but this has happened to me now 2 times in a 3 day period so I believe there is a leak. Also about my shifter I'm not sure if this applies but I have the shifter you can switch to manual (I've never switch to manual bc I don't know how to drive manual) but I have an issue with it just in automatic sometimes when I shift from park to drive it doesn't seem to switch from park to drive and the vehicle stays in the parked position while the shift is in drive and I have to shift back to park wait a second and then shift back into drive a second time before I get the truck into driving mode. I added some pictures of recalls that are for my year make and model truck that seem like the same issues I'm dealing with and wasn't sure if they applied to my vehicle and just got missed with the amount of owners it's had
- Service brakes
The contact owns a 2004 Nissan Titan. The contact stated that while operating the vehicle and depressing the brake pedal, the pedal travel distance was extended, and the vehicle would not immediately stop. After turning off and restarting the vehicle, the vehicle operated as designed. The vehicle…
The contact owns a 2004 Nissan Titan. The contact stated that while operating the vehicle and depressing the brake pedal, the pedal travel distance was extended, and the vehicle would not immediately stop. After turning off and restarting the vehicle, the vehicle operated as designed. The vehicle was taken to the local dealer who was unable to duplicate the failure. No service was performed. The failure persisted. The manufacturer was not notified of the failure. The failure mileage was 90,000.
- Engine · Power train · Structure › Body
I purchased this truck on 04/05/18 from Harbor motors Lihue Kauai, and not even a week into having this truck it started acting up, overheating, the truck wouldn't turn over, suspensions, the four-wheel-drive wouldn't disengage, when you turn the key to start the vehicle it would make a clicking…
I purchased this truck on 04/05/18 from Harbor motors Lihue Kauai, and not even a week into having this truck it started acting up, overheating, the truck wouldn't turn over, suspensions, the four-wheel-drive wouldn't disengage, when you turn the key to start the vehicle it would make a clicking noise before starting, the AC would work when it wanted to, and the transmission and engine started knocking. The next week I went running errands and when I pulled out of my yard the truck started jerking then pressed the gas and it revved really high before slamming into drive. Since then I haven't driven the truck. And today it looks like someone just smashed into the front driver light to the side and smashed it while being parked at the place I purchased the truck from. I've continuously asked for help with little to no help at all. The truck is no longer drivable and I'm still making payments on it. The lights on the dashboard has the Check enigine light on, snd the ABS
- Electrical system · Engine
While driving for 20 minutes and I'D say 25 miles per hour, my truck just stalls the electrical system working, but no engine power! The truck just stop running. In my attempt to restart the engine the starter will turn but no start. I am now stranded in traffic and if it was not for good…
While driving for 20 minutes and I'D say 25 miles per hour, my truck just stalls the electrical system working, but no engine power! The truck just stop running. In my attempt to restart the engine the starter will turn but no start. I am now stranded in traffic and if it was not for good samaritans who help me push the truck to the curb. This happened twice in the last couple of days. I've replaced my battery and it died for second time! Thankfully I was on the city street both times. Both times I waited awhile tried to start up with no success, but it started only afterwards getting a jump start!? The battery IS brand new and the hope of finding the answer IS websites at lease in the hopes of some answer and directions. eve since replaced the battery I'
- Air bags
There was a recall on my airbag/seatbelt and it since has gone out after being fixed, but they said that it was past the warranty. I had thought that airbags are life of the vehicle parts.
- Service brakes
The vehicle brakes frequently go out and start to shake and make a springy noise when you push down on them and the brakes lose power and cannot be applied safely. this may lead to a crash and nissan cannot diagnose this with certainty so intervention from nhtsa IS needed. I have learned that…
The vehicle brakes frequently go out and start to shake and make a springy noise when you push down on them and the brakes lose power and cannot be applied safely. this may lead to a crash and nissan cannot diagnose this with certainty so intervention from nhtsa IS needed. I have learned that there IS a possible faulty delta computer sensor and/or brake booster that nissan cannot problem solve very well. this problem could or has led to crashes when you cannot apply the brakes at speed. it only happens when driving and the only way to stop it IS for the vehicle to be pulled over to the side of the road and shut off and restarted. Please put out a recall for this so that way there are no crashes that can injury my family or others.
- Service brakes
Same times losing brakes brake pedal very sponge soft and hardly no brakes to stop the car and the same time makes fun noise and brake light go on .when this happens sun I come to a complete stop I turn off the ignition and I start ignition again and it get back to normal I ben have this problem for a list 12 years I think this happens a list once a month.
- Suspension
TL* the contact owns a 2004 nissan titan. The contact stated that on two separate occasions, the cv axle located on the front differential detached from the vehicle while driving at various speeds, without warning. The contact had yet to take the vehicle to be serviced or diagnosed. The…
TL* the contact owns a 2004 nissan titan. The contact stated that on two separate occasions, the cv axle located on the front differential detached from the vehicle while driving at various speeds, without warning. The contact had yet to take the vehicle to be serviced or diagnosed. The manufacturer was notified of the failure and informed him that there was no recall on the vehicle. The contact was also informed that the vehicle was out of warranty and no further assistance was offered. The vehicle was not repaired. The failure mileage was approximately 135,000.
- Electrical system · Service brakes
This seems to be an issue for a lot of people so I'm officially reporting. I've owned this car for 16 years. in that time, I've repeatedly had issues with the braking system at different times starting in 2006, but definitely in 2009. I've brought it up with dealers in both saco, me & wake…
This seems to be an issue for a lot of people so I'm officially reporting. I've owned this car for 16 years. in that time, I've repeatedly had issues with the braking system at different times starting in 2006, but definitely in 2009. I've brought it up with dealers in both saco, me & wake forest, nc. each time they cannot find a problem. finally after the last time the dealer said there was a bulletin about the computer needing an update. which cost multiple hundreds to install. this install definitely decreased the incidents of multiple brake failings while driving, but didn't completely fix the problem. I'm just now learning that it's a faulty delta stroke sensor in the brake booster and IS a known problem to nissan for the titan and armada models. I never got the postcard about the class action lawsuit, but it wouldn't have helped since they never identified the issue or maybe even hid it from me during my visits. because of this I'm out of the window for the lawsuit and am still having problems. my '04 still only has 78,000 miles and multiple other people are having this same issue. nissan just had to pay 25 million to a family that was hit by one of these affected vehicles, but still will not claim there IS an issue with the delta sensor and brake booster. please make them fix this issue to save lives and pay for something they know has been an issue for a very long time. the booster can be reset and the problem goes away, but to do this you have to stop the car with the brakes fluttering and not responding. then you shut off the car for 10 seconds and restart the car. this usually fixes the issue, but it can return at any time. usually when you've already been driving for awhile. started back in 2006, but got worse in 2009. computer fix lessened issue, but still occurs at random times.
- Fuel/propulsion system · Service brakes
1/ I was driving on highway when truck just shut down . Fuel gauge reads that truckhas 1/4 tank left of fuel but gas tank empty. 2/ while driving the brake pedal goes to the floor like it has no brakes. I check the fluids and its full. Turn the truck off and on and it works again . *tr
- Electrical system · Engine
TL* the contact owns a 2004 nissan titan. The contact stated that on several occasions while driving at undisclosed speeds or stopped at a traffic light, the vehicle stalled without warning. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ecm…
TL* the contact owns a 2004 nissan titan. The contact stated that on several occasions while driving at undisclosed speeds or stopped at a traffic light, the vehicle stalled without warning. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ecm relay needed to be replaced. The contact was then referred to naples nissan (3640 pine ridge rd, naples, fl 34109, 239-300-2765. The dealer informed the contact that the vehicle was not subjected to a recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 159,500.
- Air bags · Seats
On april 16/2020 @ 330 pm. Unknown,the ceiling airbags and front seats airbags, suddenly exploded while the vehicle was parked as a result of this malfunction, no body was on the vehicle at that time. The vehicle cannot be used, since it compromises the safety of the person and passengers and the driving and handling of this vehicle.*dt*jb
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 110090672004 - 2015 TITAN; VIBRATION AT 40 50 MPH This bulletin is no longer active. Please discard previous versions of NTB17-110.
- 11007000VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2004-2012 Armada, 2004-2012 Titan, and 2004-2009 Quest vehicles, to inspect and if necessary, replace the driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification numbers PC944, PC946, PC947 and PC949 to this campaign. The vehicle specific number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealers responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealers inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11004962VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001201WINDOW GLASS WARRANTY INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001194REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001191WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10243708DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10239062SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
- 1023906012 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect Test with DCA and Replace results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000 CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/ DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
- 10235710INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
- 10235707VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232658REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232657WHEEL BEARING COLLISION DAMAGE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232656WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232652DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10206391STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10192821SERVICE INFORMATION Replacement 5-speed rear wheel drive Automatic Transmission (A/T) assemblies and replacement control valves (valve bodies) now come with blank Transmission Control Modules (TCMs). Blank TCMs come without software and must be programmed (not reprogrammed) and then configured after they are installed. When ordering a replacement A/T or control valve, use the Nissan electronic parts information systems to obtain the correct software program part number See this bulletin for further detail.
- 10192805IF YOU CONFIRM A refrigerant leak at a refrigerant pipe/hose joint location. ACTIONS 1. Inspect the metal surfaces of the pipe/hose joint for damage or contamination. NOTE: Do not replace a refrigerant pipe, hose, or other A/C component if an o-ring seal will solve the leak incident, if it should occur. 2. If no damage is found to the joint metal surfaces, replace the O-ring seal. See this bulletin for further detail.
- 10192801SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement "Certification Label" or "VIN Plate / Label" may be needed. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. See this bulletin for further detail.
- 10192747IF YOU CONFRIM An oil leak at the right side block ball plug behind the alternator. ACTION Use a punch to seat the block ball plug in the hole (refer to the Service Procedure). NOTE - Do not replace the engine block for this incident if it should occur. See this bulletin for further detail.
- 10192679SERVICE INFORMATION Power moonroof initialization procedures for the Applied Vehicles have been revised. The procedure described in this bulletin differs from the procedure in the Electronic Service Manual (ESM). At a later date and where possible, the applicable ESMs will be updated with the revised procedures. Follow the procedure in this bulletin should the power moonroof in an Applied Vehicle need to be initialized. See this bulletin for further details.
- 10192677SERVICE INFORMATION Windshield "foreign material" that is on the surface of the glass in some cases can be cleaned off with a very particular type and grade of steel wool. * Most any foreign material on the surface of the Windshield can be cleaned off by using #0000 super fine steel wool. >The #0000 grade super fine steel wool can be found in most hardware stores. Please see this bulletin for further details.
- 10192638SERVICE INFORMATION This bulletin has compiled Tire Pressure Monitor System (TPMS) and Low Tire Pressure Warning System (LTPWS) information for: - Basic diagnosing of TPMS/LTPWS systems - Radio frequency interference causing a "No Data" (C1708, C1709, C1710, C1711) condition - Sensor leaks - Moving TPMS/LTPWS wheel assemblies from one vehicle to another and TPMS/LTPWS sensor registration - Air pressure changes with altitude and ambient temperatures - Aftermarket tire sealers - Aftermarket wheels - Inflating/deflating tires with TPMS/LTPWS sensors See this bulletin for further detail.
- 10192524SERVICE INFORMATION When diagnosing possible power steering gear (rack and pinion steering rack, or steering rack) leak issues, it may appear the steering rack is leaking when actually, it?s not. Use this service bulletin to help make a more accurate diagnosis of the steering rack. See this bulletin for further detail.
- 10192513SERVICE INFORMATION Changes or modifications to the front seat assembly trim materials may affect the proper operation of the Front Seat-Mounted Side-Impact Supplemental Air Bags and Passenger Occupant Classification Sensor and could result in serious personal injury or death. Nissan STRONGLY RECOMMENDS AGAINST making any change to seat trim materials from the factory equipped condition. This specifically applies to replacing the seat trim with non-factory materials; adding leather/cloth seat covers, seat pads, or seat storage pouches, etc. around or over the seat back and the passenger seat cushion. See this bulletin for further detail.
- 10192326SERVICE INFORMATION The specifications for the intake and exhaust valves and valve lifter service parts have been changed. * The valve stem length of both intake and exhaust valve has been increased (Figure 1) and are a direct replacement for the shorter style valve. * The related valve lifter cup has been shortened (Figure 2) and the point at which the valve lifter contacts the valve stem has been shortened (not shown). These service parts will require that the valve and valve lifter be replaced at the same time. See this bulletin for further details.
- 10192305SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the "RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF, disconnect both battery terminals, and wait at least 3 minutes before performing any service on the SRS. See this bulletin for further detail.
- 10192234Two methods are used to update/upgrade Navigation Map Data: 1. The customer goes to www.nissannavigation.com and is mailed update disc(s) or SD Card and installs data, OR 2. The dealership is mailed update disc(s) and the customer must visit the dealership to have data installed. Use the matrix in this bulletin to determine which method is utilized for each Applied Vehicle. See this bulletin for further detail.
- 10192233Nissan Original Equipment or Genuine Accessory Alloy wheels, along with their finish coating (clear, chrome, titanium, etc.), are specifically developed to achieve Nissan design and performance standards. These Original Equipment or Genuine Accessory wheels are subjected to testing to ensure they meet Nissan's standards. Nissan Original Equipment Alloy or Genuine Accessory wheels subjected to aftermarket chroming may no longer continue to meet these standards and may be seriously damaged. Therefore, Nissan most strongly discourages, and recommends that these wheels NEVER be subjected to, aftermarket chroming. See this bulletinfor further detail.
- 10192217If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut PFM Series brake lathe has been chosen as the approved tool for rotor resurfacing. - The ProCut PFM Series brake lathe can be ordered from TECH-MATE at 1-800-662-2001. - ProCut technical support or service can be obtained by calling 1-800-543-6618. NOTE: Brake rotors may need to be resurfaced during routine brake repair or for brake "judder" incidents. - Brake judder: A brake pedal pulsation and/or steering wheel shimmy when braking that occurs when there is too much thickness variation of the brake rotors (see NTB00-033). See this bulletin for further detail.
- 10192216SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into the following categories: a. Brake Noise: A squeak, squeal, clunk, or groan that occurs when the brakes are applied or released. b. Brake Judder: A vibration that can be felt in the vehicle, steering wheel or brake pedal when the brakes are applied. c. Pedal Feel: The effort needed to operate the brakes is too high or too low. SERVICE PROCEDURE 1. Verify the condition by road testing the vehicle with the customer. 2. Determine the specific brake incident based on the description in the Service Information above. 3. Follow the appropriate repair procedure(s), listed on the following pages, for your specific incident. See this bulletin for further details.
- 10192192As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed self diagnosis of major emissions systems and components. - In these instances the State may require completion of the SRT before permitting the emissions inspection to proceed. Refer to this Bulletin for further details.
- 10192164IF YOU CONFIRM The red Air Bag warning lamp is ON, and/or the driver or front passenger seat belt is not working correctly, and/or the rear audio speakers are not working correctly, and/or the customer has requested an inspection of the above items, ACTIONS 1. Check Service Comm to determine if Campaign R0616 has been performed. - If campaign R0616 has not been performed, this bulletin does not apply. 2. Follow the Repair Flow-Chart in this bulletin. See this bulletin for further detail. (PC198)
- 10192145SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition which is considered normal, does not affect strut/shock absorber operation or performance, and does not require replacement. - A strut or shock absorber that should be replaced due to rod resistance/noise issues. See this bulletin for further detail.
- 10188377STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10179614VK56 CONNECTING ROD CAP BOLT SERVICE INFORMATION SERVICE INFORMATION A change has been made to the connecting rod cap bolt service part. The new service part (B in Figure 1) is visually different, but is a direct replacement for the original equipment part. IMPORTANT: See page 2 for the procedure to inspect the cap bolt service part for excessive stretch. If replacement of a single connecting rod cap bolt is indicated for any given connecting rod, both connecting rod cap bolts of the affected connecting rod must be replaced as a set.
- 10152515OBD II EVAP Tube Warranty Enhancement The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make regional and dealer personnel aware that we are re-notifying customers at this time.
- 10152514NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make regional and dealer personnel aware that we are re-notifying customers at this time.
- 10144513NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. This bulletin has been amended. Changes have been made throughout. It is necessary for you to read this revised procedure to properly perform this action. Please discard previous versions of this bulletin.
- 10144508NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. This bulletin has been amended. Changes have been made throughout. It is necessary for you to read this revised procedure to properly perform this action. Please discard previous versions of this bulletin.
Every Nissan Titan model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.