2017 Toyota RAV4

Recalls

3 recalls name the 2017 Toyota RAV4. Newest first.

• Electrical system › 12v/24v/48v battery

  Nov 1, 2023NHTSA 23V7340001,853,568 vehicles

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

  Risk and remedy

  Risk

  A battery short circuit increases the risk of a fire.

  Remedy

  Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.

  Full recall details →

• Equipment › Other › Labels

  Jun 28, 2019NHTSA 19V5030001,325 vehicles

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number…

  Risk and remedy

  Risk

  An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.

  Remedy

  SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.

  Full recall details →

• Tires › Temporary/emergency spare tire

  May 2, 2017NHTSA 17V295000409 vehicles

  Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.

  Risk and remedy

  Risk

  A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.

  Remedy

  Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.

  Full recall details →

Owner complaints

What owners report most

1. Electrical system109
2. Unknown or other62
3. Service brakes38
4. Exterior lighting32
5. Engine31
6. Air bags20
7. Structure19
8. Power train16
9. Vehicle speed control13
10. Fuel/propulsion system12

Latest complaints

• Sep 11, 2026NY
  Electrical system · Forward collision avoidance › Automatic emergency braking · Service brakes

  Toyota ABS Actuator Accumulator shows problems after a while. Most common on hybrid vehicles. Signs comes up such ABS Malfunction, Pre-Collision Malfunction, Low Braking Power, and lose traction control.

• Sep 9, 2026CA
  Exterior lighting
  The tail light assembly on these vehicles seems to be a reoccurring issue reported by other owners on online forums and unfortunately we seem to fall under the same category. Water and moisture constantly gets into the rear brake/turn lighting assembly and has been constantly burning out the bulbs…

  The tail light assembly on these vehicles seems to be a reoccurring issue reported by other owners on online forums and unfortunately we seem to fall under the same category. Water and moisture constantly gets into the rear brake/turn lighting assembly and has been constantly burning out the bulbs it’s become quite ridiculously expensive now. How was my safety put at risk? Well it’s the brake lights! If my brake lights are out or greatly dimmed from moisture that puts me at a higher risk of having someone rear end me at any moment! No the component has not been inspected again by the dealer! I had already brought it up once during a regular maintenance visit but was ignored. There was no warning lamps or such thing. I can not remember when it first began to give problems. But the most recent incident where I had to change out all the bulbs again was just recently on 09/02/2026

• Aug 29, 2026PACrash
  Service brakes · Vehicle speed control
  I was pulling into a parking spot in a parking garage and pressed on the brake. The brake pedal did not offer the usual resistance and went flat to the floor. The car began to accelerate and smashed into a concrete I-beam on the wall of the garage. I put the car in park and kept my foot on the…

  I was pulling into a parking spot in a parking garage and pressed on the brake. The brake pedal did not offer the usual resistance and went flat to the floor. The car began to accelerate and smashed into a concrete I-beam on the wall of the garage. I put the car in park and kept my foot on the brake but it still kept trying to move forward. Then I put it in reverse and it slowly backed away from the wall but still wouldn’t stop with the brake applied and in park. I pulled the emergency brake on and the car stopped and then I turned off the engine.

• Aug 8, 2026WA
  Unknown or other
  The sunroof/moonroof glass on my 2017 Toyota RAV4 XLE suddenly shattered while I was driving on the highway. I heard a very loud explosion-like sound, and the sunroof glass broke unexpectedly. I did not observe any object, rock, or road debris striking the sunroof before it shattered. The remaining…

  The sunroof/moonroof glass on my 2017 Toyota RAV4 XLE suddenly shattered while I was driving on the highway. I heard a very loud explosion-like sound, and the sunroof glass broke unexpectedly. I did not observe any object, rock, or road debris striking the sunroof before it shattered. The remaining damaged sunroof and vehicle are currently available for inspection upon request. This incident put my safety and the safety of others at risk because the sunroof shattered unexpectedly while I was traveling on the highway. The sudden loud sound startled me while I was driving, and broken glass was left across the sunroof area and continued to break and fall from the damaged glass. I was concerned that additional pieces could come loose while the vehicle was being driven. The problem has not yet been reproduced or confirmed by a Toyota dealership or independent repair facility. The sunroof has not yet been professionally repaired. At this time, the vehicle and sunroof have not been inspected by Toyota or a Toyota dealership regarding the cause of the failure. I have photographs and/or video documenting the condition of the sunroof after the incident. There were no warning lights, dashboard messages, or other warning symptoms before the sunroof shattered. The failure happened suddenly and without warning while I was driving on the highway.

• Aug 6, 2026NY
  Air bags · Electrical system · Structure › Body
  This vehicle has twice had the same issue where the sunroof drain lines become clogged or dislocated and the water fills the liner in the front driver and passenger seats resulting in flooding in the compartment and mold damage throughout the interior. the mole spore are transmitted throughout the…

  This vehicle has twice had the same issue where the sunroof drain lines become clogged or dislocated and the water fills the liner in the front driver and passenger seats resulting in flooding in the compartment and mold damage throughout the interior. the mole spore are transmitted throughout the interior. The water damaged the airbags and the electrical harness in the dash of the car resulting in the dashboard electrical system shutting off and restarting spontaneously while driving. The leaks were repairs and the interior replaces in october 2023 and the same incident has recurred in august 2026. The claims adjuster recommends that the entire wiring harness, airbags, and carpets, seats and liners be replaced for health and safety of passengers.

• Jul 31, 2026CA300,000 mi
  Electrical system › Instrument panel › Speedometer/odometer

  Odometer Fraud. The contact purchased a 2017 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 110,000 and at the time of a Carfax check, it was discovered that the mileage was 300,000.

• Jun 19, 2026GA
  Latches/locks/linkages › Electronic lock/latch actuator · Structure › Body › Hatchback/liftgate
  The liftgate on my 2017 Toyota RAV4 has been having issues for a couple of months. Makes a horrific noise when opening and closing. On several occasions it won't even open but about 5 inches then stops. The driver's side door won't lock/unlock with the smart key fob. I have to manually lock it and…

  The liftgate on my 2017 Toyota RAV4 has been having issues for a couple of months. Makes a horrific noise when opening and closing. On several occasions it won't even open but about 5 inches then stops. The driver's side door won't lock/unlock with the smart key fob. I have to manually lock it and then use the "key" in the fob to unlock it. It is very hard to turn the key and I am always afraid it is going to break off in the lock. I feel this is dangerous for me that the time it takes to do this, something could happen to me. I have checked a couple of places for repair of the lock and it can run between $600 and $800 per lock.

• Apr 10, 2026PA
  Unknown or other

  Rust on roof by the windshield

• Mar 26, 2026COFire
  Engine · Structure › Body · Unknown or other

  Yesterday March 25th 2026 I went to work and parked my 2017 Toyota RAV4 and about 30minutes later it was on fire in the parking lot. The fire happened around the battery area

• Feb 13, 2026WACrash1 injury
  Forward collision avoidance › Automatic emergency braking
  PCS brake has enormously engaged twice. 1. small branch fell off tree on a dirt road. brakes engaged and should not have and almost caused vehicle to slide off a 1000 foot cliff. 2. auto braked with my dog was in car and broke dogs' leg and cost a 2,000 dollar vet bill. brakes where not…

  PCS brake has enormously engaged twice. 1. small branch fell off tree on a dirt road. brakes engaged and should not have and almost caused vehicle to slide off a 1000 foot cliff. 2. auto braked with my dog was in car and broke dogs' leg and cost a 2,000 dollar vet bill. brakes where not needed i could have easily just did a slight steering adjustment to avoid collusion. the braking prevented that and almost was also almost rearended overall, the autobrake can be disabled with a lot of work on various menus. but comes on when the car is restarted. I do this every time i restart the car. I suspect a glitch or a low voltage caused it to come back on. Also trying to always remember to do it is difficult to do. I consider this auto brake to be a huge safety risk and could cause loss of life. I am so scared by this and afraid to dive the car now. may have to take a total loss on the car I just bought. Toyota dealers said they cannot reprogram the car to prevent this serious safety risk

• Feb 4, 2026CA
  Insert, padding

  While my child was sitting in his carseat, the foam head support detached from the plastic casing where it is glued together. This is not the result of any action on our part and the seat has not been in car accident. The glue just gave out.

• Jan 11, 2026WACrash1 injury
  Vehicle speed control
  I am the driver's husband and the driver was the only one in the car. I assist her to file this report The accident happened around 6 pm on 12.28.2025 My wife was involved in a single car accident in a parking lot. She made a left turn at the intersection of 192nd ave and 3rd st, and then…

  I am the driver's husband and the driver was the only one in the car. I assist her to file this report The accident happened around 6 pm on 12.28.2025 My wife was involved in a single car accident in a parking lot. She made a left turn at the intersection of 192nd ave and 3rd st, and then entered into the parking lot from the north entrance. The car hit the curb as she entered the parking lot. Then the car (RAV4) started accelerating by itself, and was out of control. She cannot stop the car. To avoid going straight and hit the shops at the other end of the parking lot, she turned the wheel to one side. She hit a light post and then hit something else. The vehicle flipped over and landed on its roof. The vehicle was totaled. She was trapped inside the car unable to free herself until the ambulance, tow truck and the police arrived. By God's grace, she did not hit any other car or person and she only suffered minor injury. She was taken to the emergency room at Peace Health, examined and released after 3 hours. If you look at the RAV4, you cannot believe that she only suffered minor injury. Praise the Lord. She is still mentally shaken up by this traumatic event. Looking at the pictures of the damage to the vehicle, the car must have been traveling at a very high speed and there is no way that the driver stepped on the gas pedal intentionally. The insurance Company is Liberty Mutual Claim# [XXX] -XX The vehicle is considered total loss by the insurance company. EDR was inspected but data in the EDR was not collected. I suspect this incident was not caused by the driver, The data in the EDR will tell the true story. I asked Liberty Mutual to retrieve the data from the EDR to prove that the gas pedal was not depressed by the driver. If the car accelerated without the driver stepping on the gas pedal, then the vehicle has safety issues. I am waiting for Liberty Mutual to retrieve the data. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• Dec 9, 2025TX
  Unknown or other
  My 2017 Toyota RAV4 suddenly caught fire while it was parked in front of my home. The vehicle was turned off and had been parked for several minutes. Without any warning, flames started in the battery area and rapidly spread, resulting in a total loss of the vehicle. The Wylie, Texas Fire…

  My 2017 Toyota RAV4 suddenly caught fire while it was parked in front of my home. The vehicle was turned off and had been parked for several minutes. Without any warning, flames started in the battery area and rapidly spread, resulting in a total loss of the vehicle. The Wylie, Texas Fire Department responded and extinguished the fire. Component or System Involved: Exact cause UNKNOWN. Fire appears to have originated from the engine compartment. The remains of the vehicle are available for inspection upon request by NHTSA, Toyota, or investigators. Safety Risk: This was a severe and unexpected fire with no warning and posed a serious risk to my family, neighbors, and surrounding property. The fire could have spread to my home and other vehicles nearby. It created a dangerous situation for anyone in the area. Reproduction / Confirmation: The problem cannot be reproduced because the vehicle is a total loss. No prior mechanical issues or symptoms suggested this could happen. Inspection Status: The vehicle has been inspected by the Wylie Fire Department, and my insurance company has opened a case and is investigating. Toyota USA has also opened a case (# [INSERT CASE NUMBER]) and is expected to review the incident. No final cause has been determined yet. Warning Lamps or Symptoms: There were no warning lights, messages, unusual smells, smoke, or performance issues before the fire. The vehicle showed no signs of trouble prior to the incident. Additional Details: I later verified that my VIN is included in an open recall related to potential fire risk. I believe this issue may be connected, but the cause is still UNKNOWN pending investigation.

• Dec 1, 2025CA
  Electrical system · Forward collision avoidance › Adaptive cruise control · Vehicle speed control
  While driving the vehicle on an uphill stretch of highway with cruise control set at approximately 65 mph, the vehicle suddenly slowed down without warning. A distinct clunk was heard at the same moment. The cruise control system attempted to restore speed, and the engine became noticeably louder…

  While driving the vehicle on an uphill stretch of highway with cruise control set at approximately 65 mph, the vehicle suddenly slowed down without warning. A distinct clunk was heard at the same moment. The cruise control system attempted to restore speed, and the engine became noticeably louder, but the vehicle struggled to return to the set speed. The driver tapped the brake to disengage cruise control and manually pressed the accelerator to resume normal speed. The trip was completed without additional events. After parking, the check engine light illuminated and the cruise control system became disabled on all subsequent drives. No warning indicators were present at the time of the initial failure, and there were no vehicles ahead that would have triggered the collision-avoidance system. Two days later, the vehicle became an intermittent no-start and eventually failed to start entirely. The vehicle was towed to a dealership for inspection. Technicians confirmed an electrical malfunction and reported that the multiplex ECU was likely experiencing an internal short. A parasitic draw test showed an abnormally high current draw of approximately 113 mA, which disappeared when the dome-light fuse and later the multiplex ECU were disconnected. The failure is intermittent and appears to involve an internal electrical short within the multiplex ECU. The sudden loss of cruise control function, abrupt deceleration, and subsequent intermittent electrical behavior created a safety risk, as the electrical malfunction occurred without warning while the vehicle was in motion. The issue was confirmed by a dealership service department.

• Nov 6, 2025VA
  Forward collision avoidance › Adaptive cruise control
  My 2017 Toyota RAV4 XLE is experiencing unsafe behavior with the Adaptive Cruise Control (ACC). When driving around modest or slight turns, the ACC frequently loses tracking of the vehicle ahead and suddenly accelerates, then harshly brakes once it reacquires the vehicle. This creates a jerking…

  My 2017 Toyota RAV4 XLE is experiencing unsafe behavior with the Adaptive Cruise Control (ACC). When driving around modest or slight turns, the ACC frequently loses tracking of the vehicle ahead and suddenly accelerates, then harshly brakes once it reacquires the vehicle. This creates a jerking motion and significantly reduces my confidence in the system. On one occasion while traveling approximately 45 miles per hour on a slight curve, the ACC began rapidly accelerating toward the vehicle in front of me as if no vehicle was there, forcing me to perform an emergency manual takeover and disengage the ACC to avoid a potential rear end collision. This issue is repeatable and appears to be related to how the ACC detects vehicles ahead while cornering. I am requesting that this behavior be investigated as a potential safety defect.

• Oct 27, 2025NC
  Unknown or other
  The rear lift hatch on my 2017 Toyota RAV4 is not working properly. It can be raised without a problem most of the time but not lowered without a lot of effort and time. It might go down several inches and stop before going back up again causing me to have to start the process all over again. It…

  The rear lift hatch on my 2017 Toyota RAV4 is not working properly. It can be raised without a problem most of the time but not lowered without a lot of effort and time. It might go down several inches and stop before going back up again causing me to have to start the process all over again. It definitely could present a danger if someone tried to force it up or down or if they got a body part under it while it was doing its weird motions. Plus it would not be safe to drive it unless it lowered all the way and latched. I did take it in to my Toyota mechanic who acknowledged the problem and said the only remedy was to replace parts at a cost of somewhere between $1200 and $1300. Since the issue with my rear lift hatch started a year ago, I have read numerous complaints from other persons who are having the same issue. My mechanic confirms that he has had a number of vehicles brought to him with the same or similar issue. I strongly feel that there should be a recall. I have been a loyal Toyota owner for many years and over the years have steered numerous persons toward purchasing a Toyota. My Rav4 is available for inspection if that is necessary.

• Sep 25, 2025IN
  Unknown or other

  My lift gate hinges on my trunk have both bent, making my trunk unable to open. This is a known issue that they have a lawsuit against them for. This is available for inspection upon request. This vehicle has been inspected and diagnosed at a certified toyota dealership. No warning signs.

• Sep 16, 2025MA
  Service brakes

  The brake system on my 2017 Toyota RAV4 LE has repeatedly failed to provide normal stopping power, even after the replacement of pads and rotors in July 2025. This poses a serious safety hazard and may indicate a defect in the braking system.

• Aug 18, 2025OH
  Power train · Steering · Unknown or other
  While driving on or around 6/5/25, an active recall on my vehicle caused damage to my battery connections causing my vehicle to completely shut off while driving on an highway exit ramp. I almost lost complete control of the vehicle. Thankfully, the vehicle turned back on and I was able to get the…

  While driving on or around 6/5/25, an active recall on my vehicle caused damage to my battery connections causing my vehicle to completely shut off while driving on an highway exit ramp. I almost lost complete control of the vehicle. Thankfully, the vehicle turned back on and I was able to get the vehicle to safety. I had to get the car towed and repaired. The repair was directly related to the damage from an active recall issue being open without remedy for over 3 years on my vehicle. When I asked Toyota for reimbursement of under $200 they refused. This is a safety issue beyond the recall and I am concerned this is going to happen to someone else and there are going to be deaths. Toyota needs to stand by their recall too and may the financial aspect correct with me. Other members of the public need to be aware of the issues beyond their recall that can affect their cars and that Toyota is requiring them to be responsible for the damage that was caused while waiting on a remedy to the recall.

• Aug 5, 2025MI237,660 mi
  Electrical system › Instrument panel › Speedometer/odometer

  Odometer Fraud. The contact purchased a 2017 Toyota RAV4. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 85,887, and at the time of registration, it was discovered that the mileage was 237,660.

• Jul 29, 2025MT
  Electrical system

  The contact owns a 2017 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, upon taking the vehicle to the dealer for the recall repair, the dealer refused to perform the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. The VIN was not available.

• Jul 24, 2025GA
  Electrical system
  The contact owns a 2017 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The…

  The contact owns a 2017 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The contact stated that while starting the vehicle, the battery power was drained, and the check engine warning light illuminated. The vehicle was jump-started. The vehicle was taken to AutoZone, and the battery was replaced. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure and instructed the contact to take the vehicle to another dealer. The failure mileage was unknown. Parts distribution disconnect.

• Jul 3, 2025TX108,000 mi
  Electrical system
  The contact owns a 2017 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The contact stated that while the vehicle was parked, the vehicle failed to start. The contact removed and replaced the battery terminal and the vehicle started. The…

  The contact owns a 2017 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The contact stated that while the vehicle was parked, the vehicle failed to start. The contact removed and replaced the battery terminal and the vehicle started. The contact took the vehicle to the local dealer for the recall repair. The local dealer refused to repair the vehicle; however, the contact was informed that there was a bulge on the side of the battery. The contact was informed to take the vehicle back to the dealer where the vehicle was purchased for assistance. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 108,000.

• Jun 24, 2025MN102,500 miFire
  Electrical system
  The contact owned a 2017 Toyota RAV4. The contact stated that while the contact's granddaughter was driving, smoke was coming from under the hood. The contact's daughter drove the vehicle to a nearby fire station. The contact stated the entire front of the vehicle was on fire, and the fire was…

  The contact owned a 2017 Toyota RAV4. The contact stated that while the contact's granddaughter was driving, smoke was coming from under the hood. The contact's daughter drove the vehicle to a nearby fire station. The contact stated the entire front of the vehicle was on fire, and the fire was extinguished. The vehicle was towed to the local tow yard. The vehicle was condemned as a total loss. The contact stated that all service appointments were provided by the dealer. In addition, the previous service appointment was performed by the dealer in June 2024. The contact's granddaughter sustained anxiety issues due to the failure. The contact stated that it was a very frightening situation for the granddaughter. The contact received notification of NHTSA Campaign Number: 23V734000(Electrical system); however, the contact stated the recall notification was received the day after the failure occurred. The manufacturer was not made aware of the failure. The failure mileage was 102,500.

• Jun 11, 2025TN
  Seat belts

  Seat belt lap buckle won't lock into the housing unit. Obviously a safety issue. Toyota told me I'm responsible to pay for the repairs . I believe Toyota has a potential recall issues here. How many people have to die before anything is done. 2017 Rav 4. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Defect investigations

NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.

• Battery Hold Down Bracket Thermal Events

  PE21005Opened Feb 25, 2021Closed Aug 12, 2024Recall 23V734
  The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI…

  The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11007455Some 2005 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.
• 11007445The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as pitting or water spots. As acid rain droplets on the vehicle surface evaporate, the concentration strength of the acid increases, causing deeper and more rapid damage. This evaporation and corrosive action also occur more rapidly on dark colored cars as direct sun heat increases. It is the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. In areas known for high frequency and/or concentration of acid rain (see Figure 1), frequent vehicle washing during high heat or humidity periods will minimize the potential for paint damage caused by acid rain. It is further recommended that either reverse osmosis or deionized water be used to prevent water spotting.
• 11007444To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible.
• 11007443Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface that resemble hard water spots. Unlike water spots however, acid rain damage cannot be removed by regular washing procedures. Also, because acid rain can etch and soften the paint, normal buffing or polishing repair procedures should not be attempted. This can cause further damage and result in visible depressions in the paint surface. The following are the three major categories of acid rain damage: Minor damage: requires only buffing to repair. Moderate damage: usually requires neutralizing, color sanding, and buffing. Severe damage: extending beyond 1/2 mil of clearcoat on a pearl, metallic, or solid color, requires neutralization, sanding, and repainting. In cases where acid rain damage is minor, neutralization and buffing with a liquid-type paint finessing product may provide an adequate repair. Only specially formulated products outlined in this bulletin should be used for that purpose. Unfortunately, other than minor damage, there is no simple method of determining the actual extent (depth) of acid penetration other than color sanding a representative affected area until there is no visible etching or depressions, followed by measuring the amount of paint removed with either a magnetic or digital-type film thickness gauge. The procedures in this bulletin are intended for use by qualified body/paint technicians and should not be attempted by inexperienced personnel. It is the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. Perform frequent vehicle washing, as often as daily, during high heat and humidity periods to minimize the potential for paint damage due to acid rain exposure. This is especially important in geographical areas known for high frequency and concentration of acid rain and industrial fallout.
• 11007433During a recent investigation of reported battery fires in 2013-2018 RAV4 vehicles with gasoline engines (excluding hybrid models), Toyota discovered that many non-Toyota retailers and others who sell or install replacement batteries were recommending a small size battery for replacement. Toyota specifies a particular size replacement battery for the RAV4 that does not include this small size. The smaller battery may not fit securely with the RAV4s battery mounting parts, and, in some cases, can move around when the vehicle is driven, causing a short circuit. Using the wrong size battery, or not installing a replacement battery properly, can cause damage to the battery and the vehicle, and it could cause a vehicle fire.
• 11006161Some 2005 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.
• 11006151The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as pitting or water spots. As acid rain droplets on the vehicle surface evaporate, the concentration strength of the acid increases, causing deeper and more rapid damage. This evaporation and corrosive action also occur more rapidly on dark colored cars as direct sun heat increases. It is the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. In areas known for high frequency and/or concentration of acid rain (see Figure 1), frequent vehicle washing during high heat or humidity periods will minimize the potential for paint damage caused by acid rain. It is further recommended that either reverse osmosis or deionized water be used to prevent water spotting.
• 11006150To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible.
• 11006149Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface that resemble hard water spots. Unlike water spots however, acid rain damage cannot be removed by regular washing procedures. Also, because acid rain can etch and soften the paint, normal buffing or polishing repair procedures should not be attempted. This can cause further damage and result in visible depressions in the paint surface. The following are the three major categories of acid rain damage: Minor damage: requires only buffing to repair. Moderate damage: usually requires neutralizing, color sanding, and buffing. Severe damage: extending beyond 1/2 mil of clearcoat on a pearl, metallic, or solid color, requires neutralization, sanding, and repainting. In cases where acid rain damage is minor, neutralization and buffing with a liquid-type paint finessing product may provide an adequate repair. Only specially formulated products outlined in this bulletin should be used for that purpose. Unfortunately, other than minor damage, there is no simple method of determining the actual extent (depth) of acid penetration other than color sanding a representative affected area until there is no visible etching or depressions, followed by measuring the amount of paint removed with either a magnetic or digital-type film thickness gauge. The procedures in this bulletin are intended for use by qualified body/paint technicians and should not be attempted by inexperienced personnel. It is the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. Perform frequent vehicle washing, as often as daily, during high heat and humidity periods to minimize the potential for paint damage due to acid rain exposure. This is especially important in geographical areas known for high frequency and concentration of acid rain and industrial fallout.
• 11006139During a recent investigation of reported battery fires in 2013-2018 RAV4 vehicles with gasoline engines (excluding hybrid models), Toyota discovered that many non-Toyota retailers and others who sell or install replacement batteries were recommending a small size battery for replacement. Toyota specifies a particular size replacement battery for the RAV4 that does not include this small size. The smaller battery may not fit securely with the RAV4s battery mounting parts, and, in some cases, can move around when the vehicle is driven, causing a short circuit. Using the wrong size battery, or not installing a replacement battery properly, can cause damage to the battery and the vehicle, and it could cause a vehicle fire.
• 11005153Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination.
• 11005149Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the presence of small, red or brown particles on the paint surface. These particles are often difficult to see on dark color paints but can be easily felt when brushing a hand across horizontal body surfaces such as the hood, roof, or deck lid.
• 11005132TECHNICAL INSTRUCTIONS FOR CONSUMER ADVISORY 24TE03 Rav4 Battery Class Action Settlement CERTAIN 2013 2018 Model Year RAV4
• 11005131On April 9, 2024, a settlement of claims for certain 2013-2018 model year Rav4 vehicles was preliminarily approved by the federal court. The court will hold a Fairness Hearing on November 19, 2024 to determine if the settlement should be finally approved. The settlement includes Toyotas agreement to provide a Customer Support Program for certain 2013-2018 model year Rav4 vehicles which were inspected/repaired under Consumer Advisory 21TG01.
• 11005130On April 9, 2024, a settlement of claims for certain 2013-2018 model year Rav4 vehicles was preliminarily approved by the federal court. The court will hold a Fairness Hearing on November 19, 2024 to determine if the settlement should be finally approved. The settlement includes Toyotas agreement to provide a Customer Support Program for certain 2013-2018 model year Rav4 vehicles which were inspected/repaired under consumer advisory 21TG01. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement. This is NOT a recall or a service campaign, but is provided to reassure owners that Toyota stands behind the reliability of our vehicles.
• 11005129During a recent investigation of reported battery fires in 2013-2018 RAV4 vehicles with gasoline engines (excluding hybrid models), Toyota discovered that many non-Toyota retailers and others who sell or install replacement batteries were recommending a small size battery for replacement. Toyota specifies a particular size replacement battery for the RAV4 that does not include this small size. The smaller battery may not fit securely with the RAV4s battery mounting parts, and, in some cases, can move around when the vehicle is driven, causing a short circuit. Using the wrong size battery, or not installing a replacement battery properly, can cause damage to the battery and the vehicle, and it could cause a vehicle fire.
• 11005122Some 2005 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines.
• 11005119This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 2025 model year Toyota vehicles.
• 11005115Toyota plans to conduct Safety Recall and Service Campaign follow-up notifications to owners whose vehicles have not yet had the following Safety Recall and/or Service Campaign repairs completed
• 11005114Safety Recall and Service Campaign completion is an important part of our commitment to customer satisfaction of Toyota products. Toyota will be conducting follow-up notifications to remind owners whose vehicles have not yet had Safety Recall and/or Service Campaign repairs completed in the campaigns listed
• 11005074TECHNICAL INSTRUCTIONS FOR CONSUMER ADVISORY 24TE03 Rav4 Battery Class Action Settlement CERTAIN 2013 2018 Model Year RAV4
• 11005073On April 9, 2024, a settlement of claims for certain 2013-2018 model year Rav4 vehicles was preliminarily approved by the federal court. The court will hold a Fairness Hearing on November 19, 2024 to determine if the settlement should be finally approved. The settlement includes Toyotas agreement to provide a Customer Support Program for certain 2013-2018 model year Rav4 vehicles which were inspected/repaired under Consumer Advisory 21TG01.
• 11005072On April 9, 2024, a settlement of claims for certain 2013-2018 model year Rav4 vehicles was preliminarily approved by the federal court. The court will hold a Fairness Hearing on November 19, 2024 to determine if the settlement should be finally approved. The settlement includes Toyotas agreement to provide a Customer Support Program for certain 2013-2018 model year Rav4 vehicles which were inspected/repaired under consumer advisory 21TG01. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement. This is NOT a recall or a service campaign, but is provided to reassure owners that Toyota stands behind the reliability of our vehicles.
• 11005071During a recent investigation of reported battery fires in 2013-2018 RAV4 vehicles with gasoline engines (excluding hybrid models), Toyota discovered that many non-Toyota retailers and others who sell or install replacement batteries were recommending a small size battery for replacement. Toyota specifies a particular size replacement battery for the RAV4 that does not include this small size. The smaller battery may not fit securely with the RAV4s battery mounting parts, and, in some cases, can move around when the vehicle is driven, causing a short circuit. Using the wrong size battery, or not installing a replacement battery properly, can cause damage to the battery and the vehicle, and it could cause a vehicle fire.
• 11005064Some 2005 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines.
• 11005061This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 2025 model year Toyota vehicles.
• 11005057Toyota plans to conduct Safety Recall and Service Campaign follow-up notifications to owners whose vehicles have not yet had the following Safety Recall and/or Service Campaign repairs completed
• 11005056Safety Recall and Service Campaign completion is an important part of our commitment to customer satisfaction of Toyota products. Toyota will be conducting follow-up notifications to remind owners whose vehicles have not yet had Safety Recall and/or Service Campaign repairs completed in the campaigns listed
• 11003649The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as pitting or water spots. As acid rain droplets on the vehicle surface evaporate, the concentration strength of the acid increases, causing deeper and more rapid damage. This evaporation and corrosive action also occur more rapidly on dark colored cars as direct sun heat increases. While Toyota paint quality, durability, and resistance to environmental factors is continuously being improved, it remains the responsibility of the dealer to protect and maintain the vehicles paint finish from the time of arrival at the dealership until retail delivery to the customer. In areas known for high frequency and/or concentration of acid rain (see Figure 1), frequent vehicle washing during high heat or humidity periods will minimize the potential for paint damage caused by acid rain. It is further recommended that either reverse osmosis or deionized water be used to prevent water spotting.
• 11003647To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible. SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. PD017-04. The entire bulletin has been updated.
• 11003644Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface that resemble hard water spots. Unlike water spots however, acid rain damage cannot be removed by regular washing procedures. Also, because acid rain can etch and soften the paint, normal buffing or polishing repair procedures should not be attempted. This can cause further damage and result in visible depressions in the paint surface. The following are the three major categories of acid rain damage: Minor damage: requires only buffing to repair. Moderate damage: usually requires neutralizing, color sanding, and buffing. Severe damage: extending beyond 1/2 mil of clearcoat on a pearl, metallic, or solid color, requires neutralization, sanding, and repainting. In cases where acid rain damage is minor, neutralization and buffing with a liquid-type paint finessing product may provide an adequate repair. Only specially formulated products outlined in this bulletin should be used for that purpose. Unfortunately, other than minor damage, there is no simple method of determining the actual extent (depth) of acid penetration other than color sanding a representative affected area until there is no visible etching or depressions, followed by measuring the amount of paint removed with either a magnetic or digital-type film thickness gauge. The procedures in this bulletin are intended for use by qualified body/paint technicians and should not be attempted by inexperienced personnel. While the quality and durability of paint on Toyota vehicles is continuously being improved, it remains the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. To read, While the quality and durability of paint on Toyota vehicles is continuously being improved, it remains the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to first sale. Perform frequent vehicle washing, as often as daily, during high heat and humidity periods to minimize the potential for paint damage due to acid rain exposure. This is especially important in geographical areas known for high frequency and concentration of acid rain and industrial fallout.
• 11003594The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as pitting or water spots. As acid rain droplets on the vehicle surface evaporate, the concentration strength of the acid increases, causing deeper and more rapid damage. This evaporation and corrosive action also occur more rapidly on dark colored cars as direct sun heat increases. While Toyota paint quality, durability, and resistance to environmental factors is continuously being improved, it remains the responsibility of the dealer to protect and maintain the vehicles paint finish from the time of arrival at the dealership until retail delivery to the customer. In areas known for high frequency and/or concentration of acid rain (see Figure 1), frequent vehicle washing during high heat or humidity periods will minimize the potential for paint damage caused by acid rain. It is further recommended that either reverse osmosis or deionized water be used to prevent water spotting.
• 11003592To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible. SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. PD017-04. The entire bulletin has been updated.
• 11003589Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface that resemble hard water spots. Unlike water spots however, acid rain damage cannot be removed by regular washing procedures. Also, because acid rain can etch and soften the paint, normal buffing or polishing repair procedures should not be attempted. This can cause further damage and result in visible depressions in the paint surface. The following are the three major categories of acid rain damage: Minor damage: requires only buffing to repair. Moderate damage: usually requires neutralizing, color sanding, and buffing. Severe damage: extending beyond 1/2 mil of clearcoat on a pearl, metallic, or solid color, requires neutralization, sanding, and repainting. In cases where acid rain damage is minor, neutralization and buffing with a liquid-type paint finessing product may provide an adequate repair. Only specially formulated products outlined in this bulletin should be used for that purpose. Unfortunately, other than minor damage, there is no simple method of determining the actual extent (depth) of acid penetration other than color sanding a representative affected area until there is no visible etching or depressions, followed by measuring the amount of paint removed with either a magnetic or digital-type film thickness gauge. The procedures in this bulletin are intended for use by qualified body/paint technicians and should not be attempted by inexperienced personnel. While the quality and durability of paint on Toyota vehicles is continuously being improved, it remains the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to the first sale. To read, While the quality and durability of paint on Toyota vehicles is continuously being improved, it remains the dealers responsibility to protect and maintain the quality of the vehicles paint finish after receipt at the dealership prior to first sale. Perform frequent vehicle washing, as often as daily, during high heat and humidity periods to minimize the potential for paint damage due to acid rain exposure. This is especially important in geographical areas known for high frequency and concentration of acid rain and industrial fallout.
• 10253223This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.
• 10244115TSB: The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. Follow the procedures outlined in this service bulletin to aid in locating, inspecting, and repairing refrigerant leaks
• 10244113TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.
• 10238157TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to reset a vehicle Immobilizer or Smart Key system.
• 10230369DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.
• 10230368DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.

Every Toyota RAV4 model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.