2015 GMC Yukon
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2015 GMC Yukon. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
10 recalls name the 2015 GMC Yukon. Newest first.
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic…
Risk and remedy
Risk
Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Risk and remedy
Risk
As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Risk and remedy
Risk
If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL…
Risk and remedy
Risk
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and…
Risk and remedy
Risk
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
Risk and remedy
Risk
An unexpected loss of power steering increases the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
Risk and remedy
Risk
During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
Remedy
GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
Risk and remedy
Risk
If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission…
Risk and remedy
Risk
If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
Remedy
GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
General Motors is recalling certain 2014 model year Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles, and 2015 model year Cadillac Escalade and Escalade ESV; Chevrolet Silverado HD; and GMC Sierra HD, Yukon, and Yukon XL, equipped with a 4.3L engine or 5.3L engine.
Risk and remedy
Risk
The overheated exhaust components may melt nearby plastic parts and may result in an engine fire.
Remedy
General Motors will notify owners, and dealers will reprogram the engine control module, free of charge. The recall began on January 16, 2014. Owners may contact Chevrolet at 1-800-222-1020 and GMC at 1-800-462-8782. General Motors' number for this recall is 14008.
Owner complaints
529 complaints9 involved a crash4 involved a fire9 injuries
What owners report most
Latest complaints
- Engine
The vehicle developed a recurring cylinder #4 misfire with a flashing check-engine light, rough running, and reduced performance. Diagnostic code P0304 repeatedly returned. Replacing the #4 spark plug temporarily restored normal operation, but the misfire returned after a few hundred miles. The #4…
The vehicle developed a recurring cylinder #4 misfire with a flashing check-engine light, rough running, and reduced performance. Diagnostic code P0304 repeatedly returned. Replacing the #4 spark plug temporarily restored normal operation, but the misfire returned after a few hundred miles. The #4 plug was wet/oily, and fresh oil was found pooled in the #4 intake port while the other ports were dry. All eight spark plugs, ignition coils, and plug wires were replaced, along with the #4 fuel injector and both #4 valve-stem seals, but the misfire persisted. A valvetrain/lifter tick later became audible near 3,000 RPM. The failure has now been confirmed as a valvetrain failure that severely damaged/destroyed cylinder #4 and requires complete engine replacement. The vehicle is available for inspection upon request. This defect creates a serious risk of severe misfire, loss of engine performance, or complete engine failure while driving.
- Engine · Fuel/propulsion system
While traveling at highway speeds on Interstate 5 in Oregon, my 2015 GMC Yukon Denali experienced a sudden, catastrophic engine failure with zero advance warning. The vehicle instantly lost almost all propulsion and power while surrounded by high-speed traffic, creating an immediate and severe…
While traveling at highway speeds on Interstate 5 in Oregon, my 2015 GMC Yukon Denali experienced a sudden, catastrophic engine failure with zero advance warning. The vehicle instantly lost almost all propulsion and power while surrounded by high-speed traffic, creating an immediate and severe safety hazard on a major interstate. The engine began making a loud, severe knocking noise, and I was forced to navigate across lanes without adequate power to reach the shoulder. The vehicle was towed and inspected by Point S in Creswell, OR, where diagnostics confirmed a P0300 random/multiple cylinder misfire, with cylinder 4 specifically misfiring. Using a stethoscope and scanner to isolate the failure, technicians confirmed a catastrophic rod knock failure at the bottom end of the engine. The vehicle was then taken to Sam’s Automotive Service, where a complete engine replacement was executed at a total out-of-pocket cost of $16,000. General Motors has a well-documented history of internal engine failures on these 6.2L V8 platforms, yet they have failed to issue a safety recall for vehicles experiencing this sudden, dangerous highway power loss.
- Air bags · Service brakes · Steering
My 6 year old son and I were coming down the road and came up on 2 deer and I was coming up on a sharp curve and when I hit my brakes my steering wheel LOCKED up completely and the steering wheel is so bent where I tried my best to control it but I failed and we hit a tree head on. Broke my nose and my sons leg broke in between the back seat air bag and door air bag
- Air bags · Service brakes, hydraulic
The contact owns a 2015 GMC Yukon. The contact stated that while driving at 40 MPH, the rear brakes became inoperable, causing the steering wheel to seize, with no warning lights illuminated. Due to the failure, the vehicle crashed into a tree. The contact and the contact’s child sustained…
The contact owns a 2015 GMC Yukon. The contact stated that while driving at 40 MPH, the rear brakes became inoperable, causing the steering wheel to seize, with no warning lights illuminated. Due to the failure, the vehicle crashed into a tree. The contact and the contact’s child sustained injuries and were transported to a local emergency room for medical treatment. The contact suffered a broken nose and a chest fracture. The contact’s child sustained a broken leg due to deployment of the passenger-side air bag. The contact stated that the air bags deployed during the crash; however, the driver’s air bag failed to deploy. A police report was filed. The vehicle was towed to the contact’s residence. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was not available.
- Service brakes
There is a recall on my 2015 GMC Yukon, that I am not the original owner of. The recall is for the brake booster and says that it expired. I have had the car checked by two different shops (both confirmed it was this), and one of them was the local GMC dealership by my house. I called to make an…
There is a recall on my 2015 GMC Yukon, that I am not the original owner of. The recall is for the brake booster and says that it expired. I have had the car checked by two different shops (both confirmed it was this), and one of them was the local GMC dealership by my house. I called to make an appointment for the recall to be fixed, to which they said they needed to order parts and it would take a few weeks. I dropped the car off three weeks later per their request for then another person to call me and say they won't fix it because it is expired. It is a safety matter that the breaks don't work occasionally.
- Power train
The contact owns a 2015 GMC Yukon. The contact stated that while in reverse(R), the vehicle jerked while depressing the accelerator pedal. There was no warning light illuminated. The contact became aware of fluid spots on the driveway while the vehicle was parked. The vehicle was taken to an…
The contact owns a 2015 GMC Yukon. The contact stated that while in reverse(R), the vehicle jerked while depressing the accelerator pedal. There was no warning light illuminated. The contact became aware of fluid spots on the driveway while the vehicle was parked. The vehicle was taken to an independent mechanic who discovered a leak in the transmission oil cooler line. The dealer then informed the contact about NHTSA Campaign Number: 14V152000 (Power Train); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.
- Engine
Noticed a tick sound. Sent to dealer. Lifter failed. Bent push rod. Took it in Nov 24th. Charged $7,100. Fixed all lifters and bent push rod. Was turning around in my driveway and vehicle just shut off. Took it back to same dealer in Jan 27th. Bad lifter. Same push rod. Still in shop. That’s two…
Noticed a tick sound. Sent to dealer. Lifter failed. Bent push rod. Took it in Nov 24th. Charged $7,100. Fixed all lifters and bent push rod. Was turning around in my driveway and vehicle just shut off. Took it back to same dealer in Jan 27th. Bad lifter. Same push rod. Still in shop. That’s two months and 2,000 miles and had same failure. That is absolutely ridiculous GM and I should be compensated for this. It has costed me $7100 dollars. They are fixing with a two year warranty but if the failures are so close together, who’s to say it won’t just keep happening. Not only is it a safety issue, it is hurting my finances. I drive this vehicle 2 miles to work at 25 mph, and religiously change the oil at 3,000 miles. It didn’t even get an oil change before it failed again. I am not happy and GM needs to be sued for this. I owe 20,000 on this truck and have spent 7,000 already, and it keeps failing. There needs to be a recall for this model year, and it needs to be a permanent fix. GM knows the quality of this motor is horrible and they won’t do anything about it. It’s not safe. They can my truck for $20,000
- Steering
Electric Power Steering (EPS) assist was lost while I was driving the vehicle. As a result, I had difficulty steering the vehicle without power steering and almost caused a crash.
- Engine
While driving my 2015 GMC Yukon Denali on the highway, the vehicle suddenly began shaking and lost power. I immediately exited the highway for safety and had to “nurse” the vehicle about two miles at 10–15 mph to reach home. The vehicle would no longer run afterward. A mechanic later diagnosed a…
While driving my 2015 GMC Yukon Denali on the highway, the vehicle suddenly began shaking and lost power. I immediately exited the highway for safety and had to “nurse” the vehicle about two miles at 10–15 mph to reach home. The vehicle would no longer run afterward. A mechanic later diagnosed a lifter and camshaft failure. This is a known and common issue with GM 5.3L and 6.2L engines that poses a serious safety risk when it occurs at highway speeds. No warning lights or prior symptoms were present before the failure. I did not report it to the dealer, but the vehicle had to be towed to a mechanic for diagnosis. The vehicle is available for inspection.
- Engine
6.2L engine, collapsed hydraulic lifter AFM failure, required $7400 in total repairs. All lifters, camshaft, high pressure fuel lines, high pressure fuel pump, intake manifold & miscellaneous parts and gaskets replaced by selling Dealer at 94000 miles. No help of any kind from GM or Dealer. This is a WELL KNOWN FAILURE FOR THESE ENGINES!
- Steering
Vehicle has issue turning at times message on dash says reduced steering had trouble turning and almost caused a accident
- Unknown or other
I bought a car in early 2024 ive had it for 1.5y I recently went to trade it in for something more suitable for me and they ran a carfax and mileage rollback popped up and I had no clue to begin with. They rolled back 100,000 miles on the vehicle. They’re blaming the finance company but they can’t because the finance company never had the vehicle in there possession
- Back over prevention › Warnings · Service brakes
While driving in downtown boston in heavy traffic (stop and go) braking did not stop the vehicle when removing my foot from the brake and reapplying and the braking was extremely hard, the vehicle nearly collided into the vehicles in front of me. This issue persisted continously for the duration of…
While driving in downtown boston in heavy traffic (stop and go) braking did not stop the vehicle when removing my foot from the brake and reapplying and the braking was extremely hard, the vehicle nearly collided into the vehicles in front of me. This issue persisted continously for the duration of travel. The issue was not found using the vin provided. This issue MUST be resolved ASAP. This incident was not the first, after owning the vehicle for several months this issue is a major safety issues, specifically when my new young adult drivers use this vehicle. Please help me resolve.
- Exterior lighting
Rear tail lights go out intermittently caused by a defect in the vehicle manufacturer’s process in which the circuit board is broken in certain areas.
- Fuel/propulsion system
Truck loss power turning off while making a turn into driveway with incoming traffic. Happen on several occasions. Diagnostic at dealership states high pressure fuel pump is leaking fuel internal making it run rich. NHTSA states this model truck has had previous recall.
- Engine · Power train
Driving down the expressway at 65MPH, and the Vehicle completely stops, almost causing a collision. After researching the problem at the GMC Dealer, it appears that the entire engine has internally failed. Apparently it was a Complete Engine Failure.
- Power train
The transmission failed at 59,700 miles. The transmission will shift up and down by itself. The transmission is revving up when trying to pass and the vehicle will go limp for a few seconds and then the gear with kick in really hard. In stop and go traffic the transmission slips constantly and could cause an accident due to the limp mode.
- Exterior lighting · Power train · Service brakes, hydraulic
The contact owns a 2015 GMC Yukon. The contact stated that while depressing the brake pedal, added pressure was needed before the vehicle came to a stop. The contact stated that the vehicle hesitated or jumped before coming to a stop. Additionally, the contact stated the transmission was slipping.…
The contact owns a 2015 GMC Yukon. The contact stated that while depressing the brake pedal, added pressure was needed before the vehicle came to a stop. The contact stated that the vehicle hesitated or jumped before coming to a stop. Additionally, the contact stated the transmission was slipping. The contact stated that while driving at various speeds, the vehicle stalled before self-correcting. The contact also stated that while idling at a stop light and attempting to accelerate, the vehicle hesitated, but gradually accelerated as needed. The contact stated that the rear taillight intermittently failed to illuminate. The contact stated that the check engine warning light was illuminated. The transmission fluid was flushed; however, the failure recurred. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the transmission was fractured, and the light bulbs needed to be replaced. The transmission was not repaired or replaced. The headlights were not replaced. The dealer confirmed that the brakes were included in NHTSA Campaign Number 19V645000 (Service Brake, Hydraulic) and the vehicle was repaired; however, the failure persisted. The vehicle was driven to the residence without further repairs. The contact stated that the vehicle had become inoperable. The manufacturer was not informed of the failure. The failure mileage was approximately 195,846.
- Engine and engine cooling
The contact owns a 2015 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed…
The contact owns a 2015 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with compression in cylinder 7, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 100,000.
- Engine
Started my 2015 Yukon XL, drove approximately 6 miles to get gas and was to head out onto the highway. After gassing up and starting engine it began to idle very rough with a shake going on and ticking noise. No previous signs of any issues. Slowly drove back to my house at 20 miles an hour and…
Started my 2015 Yukon XL, drove approximately 6 miles to get gas and was to head out onto the highway. After gassing up and starting engine it began to idle very rough with a shake going on and ticking noise. No previous signs of any issues. Slowly drove back to my house at 20 miles an hour and called Mandal GMC dealership. They suggested having it towed to them for inspection. Upon inspection they said the AFM/DOD #1 exhaust lifter was bad and needed replaced. They replaced all of Bank one lifters and said their was no damage to camshaft. Drove it that night after repairing it and everything seemed fine. They called the next morning and said when they started it up the ticking was back again. They then supposedly took off head cover and inspected the camshaft again and said it was damaged and I would need a new engine to the tune of $18,000.00. I purchase it in 2021 from them use and paid $33,000.00 and now still owe even more than the engine repair. I said it would cost more than the vehicle was worth and they had done $4,000.00 of repair that didn’t even get the issue fixed. I am a senior on Social Security and can not afford to continue to pay 20,000.00 for the loan and then another $18,000.00 for a faulty engine design that caused the problem in the first place. May have to join the thousands of others in the class action to get GM to not put out such untrustworthy engineering. Now $37,000.00 piece of Yard Sculpture !! The morning that it occurred was the first sign of flashing engine warning on dash.
- Engine
The Yukon was driving normally and just lost power while driving 55mph on the highway. Then I got off the highway to pull over and check it out and the Yukon started shaking while running and in Park. The truck would not drive over 30mph without shaking and what sounds like misfiring.
- Engine
With my child in the car, on a highway with no shoulder, I experienced lifter failure. It caused the vehicle shake and lose power with cars driving behind me at 55-60 MPH with nowhere to pull over. The engine just stopped as I was finally able to make it to a driveway safely. Problem was identified…
With my child in the car, on a highway with no shoulder, I experienced lifter failure. It caused the vehicle shake and lose power with cars driving behind me at 55-60 MPH with nowhere to pull over. The engine just stopped as I was finally able to make it to a driveway safely. Problem was identified by dealership and my engine had to be rebuilt. I purchased the car second hand 3 months prior with no warning or symptoms. The car was inspected at the dealership by the extended warranty company rep. The extended warranty only cover a portion of the cost. The collapsed lifter cause damage to the camshaft and bent rods. The car only had 107,000 miles. If I were not able to pull off before the engine stopped, my daughter and I could’ve easily got rear ended on a Major state highway. The car was difficult to control due to the engine shaking the entire SUV.
- Fuel/propulsion system
Fuel line rubs between cab and tank making a hole. Fuel pours out on when driving or running. Huge fire risk. Glad I caught it before the car burned up with us in it.
- Service brakes, hydraulic
The contact owns a 2015 GMC Yukon. The contact stated while driving 5 MPH, the brake pedal was depressed, but the vehicle failed to stop as intended. The brake warning light was illuminated. The contact stated that the brake pedal was depressed to the floorboard. The vehicle was slowly driven to…
The contact owns a 2015 GMC Yukon. The contact stated while driving 5 MPH, the brake pedal was depressed, but the vehicle failed to stop as intended. The brake warning light was illuminated. The contact stated that the brake pedal was depressed to the floorboard. The vehicle was slowly driven to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The contact associated the failure with NHTSA Campaign Number: 19V645000 (SERVICE BRAKES, HYDRAULIC). The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
- Engine
2015 6.2l yukon lifter failure oil changed 2000 miles ago and lifter failed and possible cam damage due to AFM lifter failure vehicle has 115,000 Miles and Gm knows about these lifter failures that can blow engines and cause serious accidents due to rapid loss of power and controls that GM already…
2015 6.2l yukon lifter failure oil changed 2000 miles ago and lifter failed and possible cam damage due to AFM lifter failure vehicle has 115,000 Miles and Gm knows about these lifter failures that can blow engines and cause serious accidents due to rapid loss of power and controls that GM already knew paid alot of money as a certified pre- owned and failed to disclose lifter defects to their customers now at shop for complete inspection and now needs possible new engine when all service requirements were met now looking at thousands of dollars for repairs if known i would have not bought the vehicle. And deceiving GM customers , currently waiting for diagnostic in writing but the courts approved recall already from same issues on 2019 and newer but same lifters are in the same 2015 AFM system
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Brake Vacuum Pump Failure
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado…
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011989This service bulletin provides information on the harmful effects of ethylene glycol in transmission fluid.
- 11011900This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 11011805This Preliminary information communicates a GM part number forreflective high temperature heat or insulating tape when repairing wiring harnesses.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11011709This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
- 11011444This Preliminary information communicates to the dealer a process for accessing the procedure to add attachments to a GM technical assistance case using the dealer case management tool.
- 11011436This Preliminary information communicates for Technicians installing a Service Replacement Transmission Assembly to contact Technical Assistance to make sureunit is not suspect of a snap ring concern prior to installation.
- 11011420This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the dealer contacts TAC.
- 11011205This informational bulletin explains Unscheduled Supplemental Services and the importance of GM Simplified Maintenance Schedules.
- 11011119This Preliminary information communicates to dealers GM is working on a solution for outdated Apps
- 11010576This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
- 11010566This service bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
- 11010545This service bulletin provides information on key code security rules and information on GM keycode look-up applications (U.S).
- 11010495This bulletin provides information on Warranty Administration Required Operating Procedures - 8 Points (U.S. Only).
- 11010491This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 11010490This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11010488This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.
- 11010421This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
- 11009764This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
- 11009756This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management.
- 11009532This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009170This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11009039This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
- 11009037This service bulletin provides information on Enhancing Field Product Reports with Digital Pictures.
- 11008986This Preliminary information communicatesdirection and examples when diagnosing multiple DTCs, one of which includes U**** Byte 71 DTC.
- 11008966This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customers concern of No Forward Gear When Shifting from Park to Drive and/or Reverse to Drive.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11008906This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
- 11008898The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect.
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007788This Preliminary Information communication advises the technician on a parts restriction on the Generation I 8 speed rear wheel drive valve bodies.
- 11007780This Preliminary Information communication advises the technician on a parts restriction on the Generation I 8 speed rear wheel drive valve bodies.
- 11007776This Preliminary Information communication advises the technician that some vehicles may have a dim Driver Information Center when the interior of the vehicle is hot from a sun load or extended heater operation. The Driver Information Center is designed to dim with high temperature exposure. This is done to protect the Driver Information Center from damage.
- 11007771This Preliminary information communicates diagnostic information for vehicles with transmission noise.
- 11007761This Preliminary Information communication provides information to the technician that a customer may request the factory Integrated Trailer Brake Control be bypassed and their aftermarket trailer brake controller be installed instead. Technician will need to gain access to the body harness. Install trailer brake controller harness General Motors part number 23184088 into Middle Bus Electrical Center (X61A).
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
Every GMC Yukon model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.