2020 Lincoln Navigator
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Lincoln › Navigator › 2020
These records cover every 2020 Lincoln Navigator. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
13 recalls name the 2020 Lincoln Navigator. Newest first.
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Risk and remedy
Risk
Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy
Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Risk and remedy
Risk
Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy
Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Lincoln Navigator vehicles. A short circuit within the battery junction box can cause an engine fire while driving or parked.
Risk and remedy
Risk
A vehicle fire increases the risk of injury.
Remedy
Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's numbers for this recall are 22S36 and 22S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 23, 2025.
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A…
Risk and remedy
Risk
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Risk and remedy
Risk
Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy
Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.
Risk and remedy
Risk
Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.
Remedy
Dealers will update the body control module software, free of charge. Owner notification letters were mailed June 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S56.
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208…
Risk and remedy
Risk
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.
Risk and remedy
Risk
Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy
Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Risk and remedy
Risk
Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy
Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 2024. Ford's number for this recall is 23S48.
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the…
Risk and remedy
Risk
Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy
Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Risk and remedy
Risk
Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy
Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles. The attachment bracket for the driver's side second-row seat headrest may not have been sufficiently welded to the seat frame. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Risk and remedy
Risk
An improperly welded headrest bracket may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy
Ford will notify owners, and dealers will inspect the seat structure and replace it as needed, free of charge. This recall began July 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C12.
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the…
Risk and remedy
Risk
If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy
Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Owner complaints
32 complaints2 involved a crash2 involved a fire1 injuries
What owners report most
Latest complaints
- Power train
The contact owns a 2020 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.…
The contact owns a 2020 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving toward a red light at 10 MPH, the transmission unexpectedly shifted into park(P), causing the contact's chest to strike the steering wheel. The engine then shut off. The vehicle was restarted, and the Hill Assist, Pre-Collision, and another unknown warning light were briefly illuminated before turning off. Additionally, the transmission was slipping while driving. The dealer was made aware of the failure but confirmed that parts were not yet available. The manufacturer was notified of the failure by phone. The failure mileage was approximately 103,000.
- Seat belts
On August 20, 2026, I was driving my 2020 Lincoln Navigator and came to a complete stop at a traffic light. While I was sitting stationary at the light, with no collision, impact, sudden braking, or other event, I suddenly heard a very loud noise that sounded like a gunshot. At the same time, the…
On August 20, 2026, I was driving my 2020 Lincoln Navigator and came to a complete stop at a traffic light. While I was sitting stationary at the light, with no collision, impact, sudden braking, or other event, I suddenly heard a very loud noise that sounded like a gunshot. At the same time, the driver-side seat belt violently tightened and pulled me back into the seat. The seat belt tightened with enough force to leave marks across my chest and stomach. I was able to get myself out of the seat belt, but afterward the seat belt remained extremely tight and locked in place and could no longer be used normally. My vehicle had previously been identified as being affected by a Lincoln/Ford recall involving the seat belt pretensioner. Several months ago, I received notification instructing me to bring the vehicle to a Lincoln dealership to have the recall addressed. I scheduled the repair and brought the vehicle to the dealership approximately two weeks later. At that time, I was informed that the recall had been paused and that the dealership could not perform the repair because Lincoln did not have an available remedy/replacement part. I continued driving the vehicle because Lincoln had not provided a repair or instructed me that the vehicle should not be driven. The seat belt pretensioner has now unexpectedly deployed while the vehicle was completely stationary and without any accident or impact. The Lincoln dealership has informed me that they expect it may take approximately one month to obtain the replacement part needed to repair the vehicle. I have also contacted Lincoln Customer Support, and a case has been opened regarding this incident. I am reporting this because this was a serious and frightening safety failure. The seat belt pretensioner deployed without a collision or other apparent reason and tightened with enough force to cause visible marks on my body. I am concerned that this defect could cause more serious injuries if it occurs to other drivers
- Power train
On August 20, 2026, while traveling about 45 MPH, I accelerated to merge onto a highway while passing a slow-moving semi, with traffic approaching from behind. The transmission unexpectedly disengaged and the vehicle completely lost propulsion. The gear indicator showed Neutral. The engine rapidly…
On August 20, 2026, while traveling about 45 MPH, I accelerated to merge onto a highway while passing a slow-moving semi, with traffic approaching from behind. The transmission unexpectedly disengaged and the vehicle completely lost propulsion. The gear indicator showed Neutral. The engine rapidly increased RPM/redlined but the vehicle would not accelerate. I pressed the Drive selector to re-engage the transmission. The vehicle lurched/slammed before Drive engaged and propulsion returned. This created a serious collision risk while merging into highway traffic. This is not an isolated incident. For approximately four years the vehicle has intermittently exhibited rough/abnormal shifting or slipping during acceleration, progressively worsening. During a previous loss-of-propulsion incident on a two-lane highway, the failure occurred while passing a semi with oncoming traffic, creating a risk of a head-on collision. We repeatedly discussed the transmission problem with dealership personnel. Because it was intermittent, the dealer said diagnosis required leaving our primary family vehicle for several weeks, without a loaner. The selling dealer, about six hours away, later offered to retrieve the vehicle and provide a loaner, but canceled because no loaner was available. The defect was therefore never successfully diagnosed or repaired. After the August 20 incident, dealer-provided connected-vehicle diagnostics recorded a Powertrain System Fault and TCM codes P27B5 (Transmission Gear Ratio Control Performance), P2796 and P07E6. The vehicle is parked and available for inspection because I consider it unsafe to drive. It is also subject to open NHTSA Recall 26V402/Ford 26S48 involving the transmission/parking system; no remedy is currently available.
- Seat belts
The contact owns 2020 Lincoln Navigator. The contact stated while driving 20 MPH, occupied with his wife in the vehicle, he heard a loud explosion noise coming from inside the vehicle, and as his wife leaning forward the seat belt deployed on his front passenger side of the vehicle causing his wife…
The contact owns 2020 Lincoln Navigator. The contact stated while driving 20 MPH, occupied with his wife in the vehicle, he heard a loud explosion noise coming from inside the vehicle, and as his wife leaning forward the seat belt deployed on his front passenger side of the vehicle causing his wife to sustain whiplash and brushing to her chest. A dealer or An Independent mechanic was not contacted. The vehicle was not taken to an independent mechanic or dealer for dignanoses. The manufacturer was not notified of the failure mileage was 124,000. The contact was relating the failure to NHTSA Campaign Number:25V197000(SEATBELTS) However, the part to do the recall repair was unavailable. The approximate failure mileage was 55, 884.
- Power train
CDF Drum Failure is a known issue to Ford. They have issued a technical service bulletin (TSB 22-2428) to replace poorly designed components that have since been redesigned. The failure mode can cause violent gear shifts (from gear 10 to gear 1) at high speeds, which is a significant safety…
CDF Drum Failure is a known issue to Ford. They have issued a technical service bulletin (TSB 22-2428) to replace poorly designed components that have since been redesigned. The failure mode can cause violent gear shifts (from gear 10 to gear 1) at high speeds, which is a significant safety concern. While driving on the highway, the transmission would not shift between gears and the car lurched. Check engine light came on and I exited the highway immediately. I took my vehicle to be looked at, and they diagnosed the problem as CDF Drum failure. Ford needs to take responsibility for their problematic design in these vehicles.
- Exterior lighting
Both front headlight and rear headlight seals are faulty resulting in a water leak, causing headlight and taillights to become inoperable at 60k miles.
- Power train
2020 Lincoln Navigator, 10R80 transmission. Following two full transmission replacements, torque converter replacement, valve body replacement, and transmission pump repair, vehicle continues to exhibit hesitation under acceleration, harsh and delayed shifting, loss of power, shaking beginning at…
2020 Lincoln Navigator, 10R80 transmission. Following two full transmission replacements, torque converter replacement, valve body replacement, and transmission pump repair, vehicle continues to exhibit hesitation under acceleration, harsh and delayed shifting, loss of power, shaking beginning at approximately 28-30 mph felt through the floorboard, and abnormal fuel consumption. Independent tire shop ruled out tires as cause. Safety Recall O1 for PCM reprogramming remains incomplete on this VIN despite multiple service visits. Vehicle has been at dealership since early-March with no confirmed repair date or Ford engineer visit scheduled
- Power train
On [XXX] at or about [XXX]., I was traveling on the highway while going up hill to pass a slow moving vehicle, in the passing lane, suddenly lost total acceleration in which a wrench light appeared as if the transmission disengaged. I was able to coast to the into the driving lane, to get to the…
On [XXX] at or about [XXX]., I was traveling on the highway while going up hill to pass a slow moving vehicle, in the passing lane, suddenly lost total acceleration in which a wrench light appeared as if the transmission disengaged. I was able to coast to the into the driving lane, to get to the shoulder of the road in which the transmission engaged back at about 10mph. I was able to continue slowly, to my destination but at lower speeds the vehicle was shaking and shifting hard. I had just purchased this vehicle, used, only having same for about a month. I had to have the vehicle towed back to the place where I purchase same, due to transmission failure on 04/25/26. To A Better Way Wholesale Auto, 49 Raytkwich Road, Naugatuck CT 06770 I waiting for a service report in what needs to be repaired or replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train
Transmission issue: Not shifting properly while on the highway and almost causing a crash by loosing power and shifted into neutral after attemting to accelerate. The next time it occured the transsmission would not down shift and I was not able to accelerate.
- Engine
Regularly maintained 2020 Lincoln Navigator at 78,000 miles experienced engine failure with no warning. No check engine light until we experienced power issues and engine shuttering. We took the vehicle directly to the mechanic within an hour of check engine light. They changed the oil and said…
Regularly maintained 2020 Lincoln Navigator at 78,000 miles experienced engine failure with no warning. No check engine light until we experienced power issues and engine shuttering. We took the vehicle directly to the mechanic within an hour of check engine light. They changed the oil and said to go to the dealer. Dealer assessed the vehicle as follows: Bottom end failure of the short block which caused a knocking noise. Confirmed metal debris in the engine oil. Seals failed and leakage occurred. Recommend complete engine replacement. This is the same issue occurring in newer models. Recalls and class action lawsuits filed due to this exact issue. This is premature engine failure requiring complete engine replacement on a 5-year-old vehicle. Major safety concern since the engine can seize up at any time. Imagine going 70 miles per hour down the highway and your engine seizes up with semi trucks around you, and your entire family is in the vehicle. This is beyond unacceptable. Now Lincoln expects us to pay $15,000+ for a new engine. Federal and state oversight organizations are created and funded by our taxpayer dollars to stop these problems and hold these manufacturers accountable. Please do something about this failure.
- Power train
Faulty Transmissions even after replacement. Fluid leaks and abrupt starting / stopping with it. Dealers can't seem to figure it out and have become a safety issue
- Electrical system · Forward collision avoidance › Warnings · Lane departure › Warning
The collision warning doesn't warn sometimes. Nothing goes off when Im approaching and or have slammed on my breaks to avoid a collision. Sometimes it goes off at a great distance when it doesn't make sense to go off. I just bought the car used and have noticed this a lot. Also sometimes lane departure corrects and sometimes it doesn't. Something is off.
- Engine
Catastrophic engine failure on 2020 Lincoln Navigator at 93,000 miles. Oil contamination in cylinder 6 caused complete compression loss due to piston ring failure. The engine suffers from failed cam phases and excessive carbon build up which are known failure points of this engine. Ford Technical…
Catastrophic engine failure on 2020 Lincoln Navigator at 93,000 miles. Oil contamination in cylinder 6 caused complete compression loss due to piston ring failure. The engine suffers from failed cam phases and excessive carbon build up which are known failure points of this engine. Ford Technical Service Bulletins 20-2423 and 23-2143 document this as a known manufacturing defect for vehicles in my build timeframe, proving Ford was aware of this problem before production. This is premature engine failure requiring complete engine replacement on a 5-year-old vehicle. The failure pattern matches ongoing class-action lawsuits against Ford for EcoBoost engine defects. Safety concern: Catastrophic engine failure without warning while driving creates risk of sudden loss of power and potential accidents. Lincoln customer service has admitted these vehicles have this issue but refused escalation despite documented manufacturing defect and broken multiple callback promises. Request NHTSA investigation into 2020 Lincoln Navigator 3.5L EcoBoost engines for premature piston ring/compression failures related to carbon buildup and failed cam phasers as documented in Ford's own service bulletins.
- Power train
Category: Power Train -> Automatic Transmission Subject: 2020 Lincoln Navigator – Repeated Missed Warranty Repairs – Transmission Neutral-Out & Violent Downshift at Highway Speed Description: On [XXX], while traveling at approximately 70 mph on [XXX], my 2020 Lincoln Navigator suddenly…
Category: Power Train -> Automatic Transmission Subject: 2020 Lincoln Navigator – Repeated Missed Warranty Repairs – Transmission Neutral-Out & Violent Downshift at Highway Speed Description: On [XXX], while traveling at approximately 70 mph on [XXX], my 2020 Lincoln Navigator suddenly downshifted, free-wheeled into neutral, then violently re-engaged into a lower gear, chirping the rear tires and nearly causing a collision. The vehicle displayed a "Shift System Fault" warning. This defect matches TSB 23-2120 (momentary neutral-out) and TSB 24-2101 (harsh/delayed engagement) for the Ford/Lincoln 10R80 transmission used in the Navigator. TSB 23-2123 (harsh/delayed engagement/shift) also applies to my model year and transmission. I purchased this vehicle in December 2023 from Performance Lexus RiverCenter (Covington, KY) with the original Lincoln 6-year/70,000-mile powertrain warranty still in effect. According to Carfax, the vehicle was owned by Airport Ford, a Ford/Lincoln dealer, for six months prior. No transmission-related repairs were performed during that period despite applicable TSBs. In March 2024, I reported abnormal shifting to Lincoln of Cincinnati. The concern was dismissed without inspection or repair, even though the TSBs applied to my VIN at that time. The [XXX] incident is the direct result of two separate failures by Lincoln/Ford dealerships to act on a known defect while the vehicle was under warranty. This is a serious safety hazard that can cause sudden loss of power and traction at highway speeds. Vehicle Details: - Year: 2020 - Make: Lincoln - Model: Navigator - Transmission: 10-speed automatic (10R80) - Mileage at Incident: 48000 - VIN: [XXX] - Date of Incident: [XXX] - Dealers Involved: Airport Ford (prior owner), Lincoln of Cincinnati (service visit March 2024) The dealer is working on the car currently will send any repair items when they are in hand INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train
Had transmission problems before this final issue. With that said the dealership ended up replacing the transmission as it was under warranty. Not even 2000 miles later we are coming back from vacation and I lost total power of the vehicle but since I was going around 70 mph we made it to the…
Had transmission problems before this final issue. With that said the dealership ended up replacing the transmission as it was under warranty. Not even 2000 miles later we are coming back from vacation and I lost total power of the vehicle but since I was going around 70 mph we made it to the shoulder of the highway. Once there the vehicle was already smoking so we all got out of the vehicle and that’s when I saw the fire, and not even 3 minutes later it was totally in gulfed in flames.
- Power train
The transmission system failed, causing jerking during acceleration. The original transmission was replaced by the dealer, so it may be available for inspection if retained by the dealer or returned to Ford/Lincoln. Jerking during acceleration can create safety risks including: unpredictable…
The transmission system failed, causing jerking during acceleration. The original transmission was replaced by the dealer, so it may be available for inspection if retained by the dealer or returned to Ford/Lincoln. Jerking during acceleration can create safety risks including: unpredictable vehicle behavior during merging or passing, potential loss of control in traffic situations, and compromised ability to maintain consistent speed or smoothly accelerate away from hazards. Yes - the dealer confirmed the problem and determined the transmission required replacement, indicating they reproduced and verified the issue. Ted Britt Ford Lincoln, Chantilly, VA inspected the vehicle. No dashboard lights.
- Seat belts
The contact owns a 2020 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.…
The contact owns a 2020 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
- Power train
Was on Interstate when there was a loud bang, the transmission shifted harshly and I lost power where the vehicle would not go faster when i hit the pedal. I was basically pumping the gas for about 3-5 seconds before transmission re engaged. It was a dangerous situation in that I was at highways…
Was on Interstate when there was a loud bang, the transmission shifted harshly and I lost power where the vehicle would not go faster when i hit the pedal. I was basically pumping the gas for about 3-5 seconds before transmission re engaged. It was a dangerous situation in that I was at highways speeds about 65-70mph and i had no throttle control for several seconds. There was no warning when it happened and it re engaged and I was able to drive the vehicle home. Ford did replace the CDF drum under warranty but there should be a recall on this transmission. The the same thing happened in my other truck, an f150 which uses the same tranmission and engine combo.
- Electrical system
My car has an unknown electrical issue that causes the car battery to completely drain and the car unable to turn on. It first started in August 2023 and after months of time at the dealership, Lincoln has never determined the cause or been able to fix it and it continues to happen. This is unsafe because it leaves me and my family stranded with no operable car.
- Power train
Transmission hard shifting when shifting down 3-1 and up 1-3 I see there is a recall for 2020-2024 navigator but mine doesnt show recalls when i looked for it
- Power train
The contact owns a 2020 Lincoln Navigator. The contact stated while at a complete stop, the vehicle shut off inadvertently. The contact stated that the vehicle restarted upon pressing the Push to Start button. The contact stated upon depressing the accelerator pedal, the vehicle jerked, was…
The contact owns a 2020 Lincoln Navigator. The contact stated while at a complete stop, the vehicle shut off inadvertently. The contact stated that the vehicle restarted upon pressing the Push to Start button. The contact stated upon depressing the accelerator pedal, the vehicle jerked, was sluggish, and made an abnormal crackling sound. The vehicle then responded as needed and the contact continued driving. There was no warning light illuminated. The contact stated that while driving at an undisclosed speed and depressing the brake pedal to come to a stop, the vehicle shut off inadvertently. The contact was able to restart the vehicle and continue driving. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure had been recurring. The vehicle was taken back to the dealer. The dealer test-drove the vehicle and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
- Power train
The contact owns a 2020 Lincoln Navigator. The contact stated that while driving 50-55 MPH and depressing the accelerator pedal, the transmission shifted into neutral(N). The contact was able to veer to the side of the road. The contact turned off and restarted the vehicle. The contact was able to…
The contact owns a 2020 Lincoln Navigator. The contact stated that while driving 50-55 MPH and depressing the accelerator pedal, the transmission shifted into neutral(N). The contact was able to veer to the side of the road. The contact turned off and restarted the vehicle. The contact was able to continue driving; however, the failure recurred while driving. The vehicle was taken to the dealer, where the contact was informed that the transmission fluid was 2-quarts low after driving 100 miles. The contact stated that the failure had been recurring more increasingly. The contact stated while driving 75 MPH and depressing the accelerator pedal, the engine revved, but the vehicle failed to respond and jerked. The contact stated that the vehicle also experienced hard shifts while attempting to shift into gear. The contact stated that the vehicle shifted into Neutral(N) while the gear shifter was in drive(D), and the vehicle started losing motive power. The contact stated that the transmission was making abnormal grinding sounds. The contact continued to drive to the dealer however, there was smoke coming from underneath the vehicle and the vehicle lost motive power at the dealer. The dealer diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and was considering buying back the vehicle. The failure mileage was approximately 45,600.
- Power train · Power train › Automatic transmission · Vehicle speed control
When driving, if the accelerator pedal is depressed to merge into the highway or overtake other vehicles, the vehicle abruptly stops accelerating, and the RPM reaches max revs. The vehicle quickly loses momentum until it abruptly slams back into gear, causing a loud bang and startling the driver.…
When driving, if the accelerator pedal is depressed to merge into the highway or overtake other vehicles, the vehicle abruptly stops accelerating, and the RPM reaches max revs. The vehicle quickly loses momentum until it abruptly slams back into gear, causing a loud bang and startling the driver. This vehicle had a TSB for similar issues that was repaired by our dealer 2 times previously. We have experienced this 2 times since the repair (A total of 4 times). One time, while attempting to accelerate onto a merge lane into traffic, the car stopped accelerating, causing a large 18 wheeler to slam on their brakes to avoid hitting us as we were running out of onramp space. The dealer performed a transmission rebuild after the 3rd time this occurred. The day after we got the car back from service, it happened again. We have video footage of the transmission slipping after the event. The dealer is unable to replicate the condition, and therefore, don't have anything they can fix without a code or system fault- apparently not even the over-revs triggered a fault. I don't trust this vehicle to be safe for my family or other motorists. I have asked for a completely new transmission and other components but am told that without their ability reproduce the issues, there is no repair. They are unable to guarantee the car's safety, but expect for me to take it back. This puts me in an impossible situation - I'm being forced to drive a car that I know is unpredictably unsafe, and am unable to ethically/morally dispose of the vehicle knowing it will be back on the road and driven by someone else. Lincoln needs to do the right thing for their customers, other motorists, and my family. Their solution was to give me an extended warranty - a nice gesture, but clearly not addressing the safety issue at hand. Note: I am unable to upload the email chain with Lincoln because the upload button below does not work. I'm happy to share any communication you need.
- Power train
Frequently while traveling at 35 mph to highway speeds, while needing to accelerate slightly to avoid traffic, change lanes, pass, etc. the Navigator needs to downshift. It drops out of gear and seems to fail to find a lower gear resulting in a neutral like gear, loss of power, engine revving…
Frequently while traveling at 35 mph to highway speeds, while needing to accelerate slightly to avoid traffic, change lanes, pass, etc. the Navigator needs to downshift. It drops out of gear and seems to fail to find a lower gear resulting in a neutral like gear, loss of power, engine revving sometimes to redline. This was happening frequently during a family Thanksgiving trip in 2023. It is very scary when this happens, especially at interstate speeds in traffic. It is very unsafe!
- Power train
Driving vehicle for an approximately 70 miles highway trip, the vehicle was experiencing some hard shifts/poor shift quality prior to overheating. Temperature in vehicle for the transmission was reading 237 degree Fahrenheit when we stopped at a light after exiting the highway. We noted smoke and…
Driving vehicle for an approximately 70 miles highway trip, the vehicle was experiencing some hard shifts/poor shift quality prior to overheating. Temperature in vehicle for the transmission was reading 237 degree Fahrenheit when we stopped at a light after exiting the highway. We noted smoke and saw oil on the exhaust, which is a concern for fire. We noted a burning smell as well. Rear hatch of vehicle was sprayed with fluid, which we think is transmission fluid, causing a visibility concern out the rear windshield. The transmission had been previously rebuilt and a prior complaint filed. There were no error messages displayed in the vehicle. I have attempted to contact the dealership but they are closed on 1/1/24. I reached out to Lincoln Concierge and filed a complaint.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008948While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
- 110079152018-2022 Expedition/Navigator "Park Brake Limited Function Service Required" Message In The IPC
- 11006036Certain 2018 - 2024 Model Year Various Vehicles Update SYNC Software In all the affected vehicles, due to an error in the SYNC software, you may experience SYNC system instability concerns and/or a failure to preserve certain settings across ignition cycles. This may result in a black infotainment screen that does not affect rear view camera, incorrect language setting, erased or unsaved radio presets, and potential inability to perform software updates.
- 11005746Some 2019-2024 Ford and Lincoln vehicles equipped with SYNC3 may experience various FordPass/LincolnWay connectivity concerns including but not limited to: missing activation prompt (pop-up) on the vehicle's center display screen when attempting to activate vehicle through FordPass/LincolnWay, incorrect location/global positioning system (GPS) reported through FordPass/LincolnWay, problems with remote commands being performed through FordPass/LincolnWay, incorrect data/information reported on FordPass/LincolnWay. These symptoms will be accompanied by diagnostic trouble code (DTC) B156D:89 in the TCU. This may be due the accessory protocol interface module (APIM) software
- 11005710Some 2019-2024 vehicles equipped with SYNC 3 may experience a programming Error - "INSTL_ERR12" while programming APIM using the Ford Diagnosis and Repair System (FDRS) or experience a frozen screen which says "updating system software" or no progress/response from module using the universal USB updater. This may be due to low memory in the APIM commonly occurring on software level NU5T-14G381-AB/BB. The current software level can be verified in the SYNC tab of Professional Technician System (PTS) or using the vehicle's center display screen, Settings > General > About. To correct the condition, run the universal USB updater. If unsuccessful, using the latest software version of the FDRS scan tool, run the service function "APIM - Reset the Accessory Protocol Interface Module Application" and select "Clear All User Data" option. The center display screen will reboot. As soon as the vehicle's center display screen displays the boot up logo, immediately reinsert the same universal serial bus (USB) drive that was utilized during the prior failed programming attempt.
- 11005305This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
- 11003146Some 2019-2024 vehicles equipped with SYNC 3 may experience a programming Error - "INSTL_ERR12" while programming APIM using the Ford Diagnosis and Repair System, or experience a frozen screen which says "updating system software" or no progress/response from module using the universal USB updater. This may be due to low memory in the APIM commonly occurring on software level
- 11001646This article supersedes TSB 23-2307 to update the Service Procedure and vehicle model years affected. Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Transit Connect, 2019-2023 Mustang, 2019-2023 Ranger, 2020-2021 Expedition/Navigator, 2020-2022 Escape/Corsair/Super Duty/EcoSport, 2020-2024 Explorer/Aviator/Transit, 2021-2024 Bronco Sport, 2022-2024 Maverick vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update theaccesory protocol interface module (APIM) software.
- 11000297Various vehicles equiped with 10R80/10R80 MHT/10R100/10R140 transmissions may require replacement of the seal kits (7153) when internal repairs are being performed. These kits come with 4 wheel drive (4WD) seals and will no longer include the 2WD seals. When working on a 2WD vehicle, any 2WD seals must be ordered separately. Refer to the parts catalog for the proper 2WD seals required.
- 10254142Some 2018-2019 Explorer and 2018-2024 Transit/F-150/Expedition/Navigator vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). Diagnosis should include checking for an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Confirm FPCM connector (Explorer - C3239, Transit - C433, F-150 - C460/C4336, Expedition/Navigator - C433/C4033) is fully seated and inspect applicable grounds (Explorer G302, Transit - G401, F-150 - G401, Expedition/Navigator - G403/G406) prior to performing guided diagnostics or replacing any components.
- 10253963Certain 2017-2020 Model Year Continental and Super Duty, 2018-2020 Navigator, 2020 Aviator, and 2020 Explorer Vehicles Replace Front and/or Side Cameras if Foggy
- 10253552Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or later, select the diagnostics tab and search for related symptoms,DTCs and keywords. The search results will be shown in the search results pane. Read and follow allTechnical Service Bulletins (TSB), Special Service Message (SSM)s or General Service Bulletin (GSB) first if abulletin specifically addresses the vehicle concern. If there are no messages, run the appropriate diagnosticpinpoint test found in the Workshop Manual (WSM). Follow the steps in the pinpoint test. Make sure to note thetitle of the guided routine, using the correct one for the vehicle's symptom or diagnostic trouble code (DTC) iscritical. Depending on the outcome of the pinpoint test, a repair validation code (RVC) may be generated eitherin the pinpoint test or Guided Routine. If the vehicle concern still exists after following the pinpoint tests orguided routine, then a manual RVC can be generated using the RVC Assist Form. A manual RVC can only begenerated once the above process has been followed.
- 10252674This article supersedes TSB 24-2046 to update the Service Procedure LTIS statement. Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang, 2019-2023 Ranger vehicles equipped with a 10R80 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) that are stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.
- 10251952For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
- 10251934During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section, 303-01 is extremely important. The bolt torque procedure can be found in the crankshaft front seal removal and installation procedure or in the engine assembly procedure.
- 10251469This article supersedes TSB 23-2350 to update the Issue statement and the Service Procedure. Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang, 2019-2023 Ranger vehicles equipped with a 10R80 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.
- 10250852Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass/LincolnWay app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep due to one of these conditions, follow normal Workshop Manual (WSM) Section 414-01 procedure to correct the concern. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
- 10248357This article supersedes TSB 23-2036 to add 2024 vehicle model years. Some 2018-2024 Navigator and Expedition vehicles may exhibit a concern where the second row seat back does not fold down or recline when the recline handle is pulled upward or the second row single seat easy entry seat fold switch is pressed. This concern may occur with vehicles equipped with two or three second row seats. This may be due to a broken recliner release lever. To correct this concern, replace the recliner release lever.
- 10246142This article supersedes 22-2475 to update the Issue Statement and Service Procedure. Some 2018-2021 Navigator vehicles may exhibit a grinding, growling, or clicking noise or inoperative power steering column during telescoping/raking operation. This may be due to a body control module B (BCMB) software issue. To correct the condition, follow the Service Procedure to reprogram the BCMB module and replace the steering column telescope or rake actuators.
- 10245418Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang, 2019-2023 Ranger vehicles equipped with a 10R80 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve. To correct the condition, follow the Service Procedure to identify and correct the condition.
- 10245354This article supersedes TSB 23-2120 to exclude Police Interceptor vehicles with column shift. Some 2018-2021 Expedition/Navigator and 2020-2021 Explorer/Aviator vehicles equipped with a 10R80/10R80 MHT or 10R60 (excluding Police Interceptor vehicles with column shift) may exhibit a momentary transmission neutral-out condition while in drive. Vehicle may also have diagnostic trouble code (DTC) P07E6 and/or P07E4 stored in the powertrain control module (PCM) or transmission control module (TCM) and/or a possible audible noise. This may be due to a leak in the park valve circuit. To correct the condition, follow the Service Procedure to inspect the park system hardware for wear or damage and replace the valve body separator plate with an improved valve body separator plate.
- 10244707Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the SYNC module (APIM) software.
- 10244704The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, or GSB, or other electronic communication. This article includes information on warranty, technical service tips and other service information
- 10243648Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability. Use the Report a Vehicle Concern link at the bottom of OASIS to submit a report if there is a customer concern of whine noise describing operating conditions and noise severity.
- 10243609Some vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash, bumped in a parking lot, or found during pre-delivery inspection (PDI). Prior to the replacement of any components, attempt to synchronize the mirrors by following the Power Mirrors Synchronization procedure. Refer to Workshop Manual (WSM) Section 501-09 Rear View Mirrors - General Procedures - Power Mirrors Synchronization.
- 10241627In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.
- 10241447This article supersedes TSB 22-2428 and 23-2176 to update the Issue, Action and Service Procedure. Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60/10R80/10R80MHT transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve. To correct the condition, follow the Service Procedure to identify and correct the condition.
- 10238875Certain 2017-2020 Model Year Continental and Super Duty, 2018-2020 Navigator, 2020 Aviator, and 2020 Explorer Vehicles Replace Front and/or Side Cameras if Foggy
- 10238468Some 2020-2023 Explorer/Aviator vehicles equipped with a 3.0L EcoBoost may exhibit an illuminated malfunction indicator lamp (MIL) and low oil pressure warning in the instrument panel cluster (IPC), with diagnostic trouble codes (DTC) P0521 and/or P0524 in the powertrain control module (PCM). This condition may be caused by an internal oil pressure leak. If pinpoint test E in the Workshop Manual (WSM) Section 303-01B directs you to the replacement of the oil pump, upon reassembly inspect that the main oil gallery tube (6718) is assembled and aligned properly on the back of the engine front cover. The engine oil gallery seal (00815) must be replaced any time the front cover is removed (per WSM Section 303-01B). The WSM front cover removal and installation procedure is in the process of being updated.
- 10238283Some 2020-2023 Explorer/Aviator vehicles may exhibit a lack of audio and/or a water leak in the rear liftgate area and/or water in the spare tire area. The customer may indicate that this concern is more noticeable after a car wash or rainfall. To correct the condition, follow the Service Procedure to identify the leak path.
- 10237977Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass/LincolnWay app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
- 10237786TSB 22-2428 is missing some labor operations. For any missing labor operations, claim available new model labor operations or m-time. Refer to this article on the repair order. When replacing the CDF cylinder, the current TSB does not require a complete transmission overhaul or cooler and converter flushing. Ford is currently reviewing the TSB. Monitor OASIS for updates.
- 10236683This article supersedes TSB 23-2123 to update the Issue statement. Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang and 2019-2023 Ranger vehicles equipped with a 10R80 automatic transmission may exhibit a harsh engagement/harsh shift/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the keep alive memory in the PCM/TCM or the transmission main control valve body. To correct the condition, follow the Service Procedure to overhaul the main control valve body and/or perform an adaptive learning drive cycle.
- 10236680Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60 transmission and built on or before 23-Dec-2022 or with a 18R80/10R80MHT transmission and built on or before 15-Aug-2022 may exhibit a harsh/delayed engagement and/or harsh/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the PCM or TCM, the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.
- 10236573Some 2018-2021 Expedition/Navigator and 2020-2021 Explorer/Aviator vehicles equipped with a 10R80/10R80 MHT or 10R60 may exhibit a momentary transmission neutral-out condition while in drive. Vehicle may also have diagnostic trouble code (DTC) P07E6 and/or P07E4 stored in the powertrain control module (PCM) or transmission control module (TCM) and/or a possible audible noise. This may be due to a leak in the park valve circuit. To correct the condition, follow the Service Procedure to inspect the park system hardware for wear or damage and replace the valve body separator plate with an improved valve body separator plate.
- 10236037Some 2017-2020 F-150 and 2018-2020 Expedition/Navigator vehicles built on or before 30-Nov-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. Some vehicles may also exhibit an intermittent condition with no auto restart during auto-start-stop operation with or without diagnostic trouble code (DTC) P164C present in the powertrain control module (PCM). This may be due to a worn variable camshaft timing (VCT) unit. To correct the condition, follow the Service Procedure to replace the VCT units.
- 10235153For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
- 10234596Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang and 2019-2023 Ranger vehicles equipped with a 10R80 automatic transmission may exhibit a harsh engagement/harsh shift/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to incompatibility of the adaptive calibration to adapt to hardware break-in over time. To correct the condition, follow the Service Procedure steps to overhaul the main control valve body and/or perform an adaptive learning drive cycle.
- 10233738Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass/LincolnWay app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
- 10233695Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability.
Every Lincoln Navigator model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.