1996 Nissan Quest
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Nissan › Quest › 1996
These records cover every 1996 Nissan Quest. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 1996 Nissan Quest. Newest first.
Vehicle description: minivans. the fuel tank vent hose allows air to vent from the fuel tank during refueling. cracks have developed in the vent hose. if (1) the fuel tank IS overfilled, not allowing excess fuel in the vent hose to flow back into the tank, (2) the vehicle IS driven only a short distance after refueling and, (3) there IS subsequently…
Risk and remedy
Risk
Fuel leakage in the presence of an ignition source can result in a fire.
Remedy
Dealers will replace the vent hose.
Vehicle description: MINI vans. these vehicles were produced with power windows that can be closed after the ignition key IS turned to the "off" position and the right front (passenger) door IS opened. this does not meet the requirements of fmvss 118, "power-operated window systems."
Risk and remedy
Risk
There IS the potential for unsupervised children to operate the power windows, increasing the risk of personal injury to the child.
Remedy
Owners will be provided with a label reminding owners not to leave children unattended because the power windows can operate for 15 minutes after the vehicle ignition has been turned off unless the driver's door IS opened. also included are instructions describing how and where this label IS to be installed. if an owner prefers, their dealer can install this label for them.
Owner complaints
134 complaints4 involved a crash6 involved a fire4 injuries
What owners report most
Latest complaints
- Fuel/propulsion system
TL* the contact owns a 1996 nissan quest. The contact noticed an abnormal fuel odor inside and outside of the vehicle while driving. The contact was unaware of a fuel leak under the vehicle or inside the vehicle. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The approximate failure mileage was 120,000.
- Structure › Body
TL* the contact owns a 1996 nissan quest. While inspecting the vehicle, it was discovered that the rear passenger side subframe was rusted and corroded. The cause of the failure was not diagnosed. The vehicle was not repaired. A local dealer was not contacted in reference to the failure. The…
TL* the contact owns a 1996 nissan quest. While inspecting the vehicle, it was discovered that the rear passenger side subframe was rusted and corroded. The cause of the failure was not diagnosed. The vehicle was not repaired. A local dealer was not contacted in reference to the failure. The manufacturer was notified of the failure, but no assistance was offered. The vin was not available. The failure mileage was 200,000.
- Fuel/propulsion system
Can not fill up the van whit gasoline,stop fill in ,like if IS full,and gasoline gauge indicates wrong reading
- Fuel/propulsion system
My nissan quest just started with gas odor. *tr
- Engine and engine cooling · Steering
TL* the contact owns a 1996 nissan quest. The contact stated while driving approximately 55 mph, the vehicle started to shake without warning. The contact was able to continue driving the vehicle. the failure occurred approximately every four months. the vehicle was taken to an independent…
TL* the contact owns a 1996 nissan quest. The contact stated while driving approximately 55 mph, the vehicle started to shake without warning. The contact was able to continue driving the vehicle. the failure occurred approximately every four months. the vehicle was taken to an independent mechanic who indicated the vehicle had a design flaw and the motor mounts needed to be replaced. the vehicle was repaired three times for the same failure. the manufacturer was notified of the failure. the approximate failure mileage was 152,799. *tr
- Fuel system, gasoline
Strong gas odor inside vehicle while drive. It got so bad it actually caused headache. I have no sense of smell was unable identify this problem sooner till headaches starting to occurring. Then other people told me that there are strong gas odor inside vehicle. I googled it and realized lots of…
Strong gas odor inside vehicle while drive. It got so bad it actually caused headache. I have no sense of smell was unable identify this problem sooner till headaches starting to occurring. Then other people told me that there are strong gas odor inside vehicle. I googled it and realized lots of people who owned 1996 nissan quest has the same problem. I called nissan dealer and was told vin # was not part of recall #00v419001 (fuel system gasoline) *kb
- Fuel system, gasoline
Strong gas odor inside vehicle while drive. It got so bad it actually caused headache. Nissan dealer was unable to identify the problem. *Kb
- Fuel system, gasoline
TL* the contact owns a 1996 nissan quest. The contact stated that the fumes from the gasoline system were entering the vehicle and becoming overwhelming. The dealer was contacted who advised the contact that the vehicle was under recall and that it would take two weeks to obtain the parts needed…
TL* the contact owns a 1996 nissan quest. The contact stated that the fumes from the gasoline system were entering the vehicle and becoming overwhelming. The dealer was contacted who advised the contact that the vehicle was under recall and that it would take two weeks to obtain the parts needed for repairs. The contact did not inform the manufacturer of the failure. The vehicle was not repaired. The vin was unavailable. The current and failure mileage was approximately 100,000.
- Fuel system, gasoline · Fuel system, gasoline › Storage › Tank assembly
My 1996 nissan quest has fuel vent problems particularly after refuel. I smell fuel inside the car and I am concerned about the risk of fire and/or explosion. this problem appears to be identical to the problem described in nhtsa recall number 00v419001. however, nissan company IS saying that my nissan's vin IS not included in the recall. *Tr
- Electrical system · Fuel system, gasoline
Tl*the contact owns a 1996 nissan quest. while driving to a stop. The contact noticed a puff of smoke near the front end of her vehicle. she stopped and exited the vehicle to look under the hood and noticed flames. she immediately slammed the hood down and removed her children from the vehicle.…
Tl*the contact owns a 1996 nissan quest. while driving to a stop. The contact noticed a puff of smoke near the front end of her vehicle. she stopped and exited the vehicle to look under the hood and noticed flames. she immediately slammed the hood down and removed her children from the vehicle. the fire department extinguished the fire and stated that a fuel leak was the cause of the failure. there were no warning indicators prior to the fire. a police report was filed. the failure mileage was 80,000. Updated 09/10/08. *lj updated 09/12/08 *jb
- Seat belts › Front › Buckle assembly
Drivers side seat belt latch broken and completely unuseable. dealer says they will fix it "under a life time warranty because it IS a safety device and has a lifetime warranty". *nm
- Air bags › Frontal › Sensor/control module
Dt: since 08-26-05 the air bag warning light stayed on. it had been turning on and off for the past two years. when the consumer had taken the vehicle to the dealership they told him that the airbag unit had to be replaced. the consumer has not yet replaced the airbag unit. there have been no accidents. the consumer felt that the airbag unit should not have to be replaced since it has never been used. *ak
- Fuel system, gasoline › Delivery › Fuel pump
1996 nissan quest fuel pump needed to be replaced.***no answer required***. *Mr while driving the vehicle made a humming noise in the engine compartment. the noise gets louder over a period of time. the vehicle was taken to two nissan dealer and three independent garage. one of the nissan…
1996 nissan quest fuel pump needed to be replaced.***no answer required***. *Mr while driving the vehicle made a humming noise in the engine compartment. the noise gets louder over a period of time. the vehicle was taken to two nissan dealer and three independent garage. one of the nissan dealers was unsure what the problem was. the other dealer said it was normal engine noise. all three independent garages agreed that the problem was the fuel pump. *nm
- Air bags › Frontal
Dt: the airbags did not deploy although the van was destroyed and totaled. Even the police couldn't believe that the airbags did not depoly. Consumer hit a deer, and the impact was on the driver's front side. neither of the two front airbags worked.*ak
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
While applying the brake pedal driver heard a loud squeaky noise. the vehicle jerked and vibrated uncontrollably. the cause has not been determined. consumer will contact the dealer in the near future. *ak
- Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
Nhtsa recall campaign 00v419001 concerning fuel tank vent hose. While driving there was a strong smell of gasoline in the vehicle. Consumer contacted the manufacturer, and was told that this vehicle was not covered under the recall due to vin although it experienced the same effects. *Ak consumer…
Nhtsa recall campaign 00v419001 concerning fuel tank vent hose. While driving there was a strong smell of gasoline in the vehicle. Consumer contacted the manufacturer, and was told that this vehicle was not covered under the recall due to vin although it experienced the same effects. *Ak consumer added when the fuel tank IS filled more than half way, the gasoline smell IS prominent. consumer has to drive with window open. *tt
- Tires
Vehicle tire deflated causing vehicle to run off the road. nar 07/02/2003 *mr the vehicle ran off the road to the right and struck a mile marker then ran into a ditch. the consumer was not hurt during this accident (ohio traffic crash report). *nm
- Latches/locks/linkages › Hatchback/liftgate › Lock
All doors will lock under 3 scenarios: 1) doors will relock immediately following, unlocking the doors. 2) doors will lock after closing driver door. 3) doors may lock without any action taking place. *ak could be locked out of vehicle if doors lock when closing door, with keys in the vehicle.…
All doors will lock under 3 scenarios: 1) doors will relock immediately following, unlocking the doors. 2) doors will lock after closing driver door. 3) doors may lock without any action taking place. *ak could be locked out of vehicle if doors lock when closing door, with keys in the vehicle. dealership replaced door lock actuator in 1998, problem started reoccuring in 2002 and continues to occur intermittently.
- Latches/locks/linkages › Doors › Latch
Latches/locks on sliding door would open, whenever the vehicle passes over a rough surface.*ak
- Latches/locks/linkages › Doors › Latch
I submitted complaint request 10051248 in december 2003. no one has contacted me about the side door continually unlatching.*ak
- Fuel system, gasoline
The interior of van would fill with a gas odor. it also had a gas leak when the tank was filled. I had it checked out at the dealer and they informed me that it was related to a manufacturer's recall of the fuel filler vent hose. they repaired it and replaced the vent hose, but the odor…
The interior of van would fill with a gas odor. it also had a gas leak when the tank was filled. I had it checked out at the dealer and they informed me that it was related to a manufacturer's recall of the fuel filler vent hose. they repaired it and replaced the vent hose, but the odor continued. I took it back for a second time but the dealer could not find anything wrong with it. the gas odor would come on mainly when the a/c was on. I contacted customer service at the dealer and all they could tell me IS that they could not find anything wrong. 1 year later after living with this gas odor my van exploded and the entire engine burned. I've called nissan and all they can tell me IS that the vehicle IS not under warranty anymore and the fire IS not related to the recall because it was only the vent hose.
- Air bags · Equipment › Electrical · Visibility › Power window devices and controls
Engine light on - computer code: anti-knock sensor estimated repair @$350. Did not repair; reset system, light did not reappear for 3,000 miles, reset again. door locks intermittent problem, esp. With slider. airbag light flashing, cannot afford repair. read light burning out bulbs (twice within 3 mos.) after market repair caused different problem.
- Air bags · Engine and engine cooling › Exhaust system · Equipment › Electrical · Power train · Seat belts · Suspension · Unknown or other · Visibility › Power window devices and controls
Weird electrical problems,i have taken to 2 different people, 1 of which specializes in transmissions, the problem IS that when the vehicle IS warmed up the transmission doesn't know what gear it IS in, on initial investigation the problem appears to be the trottle position sensor but that was…
Weird electrical problems,i have taken to 2 different people, 1 of which specializes in transmissions, the problem IS that when the vehicle IS warmed up the transmission doesn't know what gear it IS in, on initial investigation the problem appears to be the trottle position sensor but that was replaced and still no fix. They hooked up computers to the car while driving and say the computer doesn't read the tps being operative during driving but no problems can be found with the wiring and computer board. When the engine transmission starts to mess up the locks start to lock and unlock by themselves while driving, the check engine light IS on and the overdrive light blinks off and on. At one time the air bag light come on for no reason it was checked and problem found. The sliding door latch broke within a couple of months of buying. The back windshield wiper motor would also come on by itself, we ended up taking the fuse out for that.
- Engine and engine cooling · Unknown or other
My quest would take a long time to get heat into the interior. recently it started overheating as well. I replaced the thermostat, but all the instructions say to install the thermostat so the spring IS facing to the inside of the engine. however, the t'stat listed for this vehicle will not fit…
My quest would take a long time to get heat into the interior. recently it started overheating as well. I replaced the thermostat, but all the instructions say to install the thermostat so the spring IS facing to the inside of the engine. however, the t'stat listed for this vehicle will not fit with the spring to the inside of the engine; and the original t'stat (i don't think it has ever been replaced - it had nissan on it) was installed with the spring end facing the hose end. so I installed a shorter t'stat so the spring would fit toward the engine. now the interior gets heat quickly, but the engine still overheats. the radiator cap has been replaced, and the cooling system flushed. the problem eprsists.
- Visibility
Sliding side door does not say back (lock) when opened
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Fuel tank vent hose leakage
Periodic exposure to liquid gasoline may result in extraction of antidegradants from the subject fuel tank vent hose.hoses which have suffered loss of antidegradant can develop cracks in areas of high strain.fuel may spray or drip from cracked vent hoses following tank fill.starting at JOB#1 1998 my (california…
Periodic exposure to liquid gasoline may result in extraction of antidegradants from the subject fuel tank vent hose.hoses which have suffered loss of antidegradant can develop cracks in areas of high strain.fuel may spray or drip from cracked vent hoses following tank fill.starting at JOB#1 1998 my (california emissions vehicles) and JOB#1 1999 my (federal emissions vehicles), the subject vent hose composition changed from nitrile rubber hoses with chloroprene rubber covers (nbr/cr) to fluoracbon rubber hoses which an outer layer blend of nbr/pvc.the changes wer made to improve hydracarbon resistance for complaince with new evaporative emissions regulations.the modified hoses are also significantly more resistant ot degradation and craciking. In a letter dated december 14, 2000, nissan notified nhtsa that it will conduct a safety recall campaign to replace the subject vent hose in affectd vehicles with the redesigned hose.nissan will begin notifying owners of the affected vehicles on february 5, 2001.nissan will finish its owner mailings on september 10, 2001.owners will be notified in reverse order of vehicle age.
- Unexpected opening on sliding door
There is no summary currently available
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10243708DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10239062SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
- 1023906012 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect Test with DCA and Replace results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000 CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/ DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
- 10235710INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
- 10235707VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232658REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232657WHEEL BEARING COLLISION DAMAGE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232656WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232652DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10206391STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10192305SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the "RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF, disconnect both battery terminals, and wait at least 3 minutes before performing any service on the SRS. See this bulletin for further detail.
- 10192233Nissan Original Equipment or Genuine Accessory Alloy wheels, along with their finish coating (clear, chrome, titanium, etc.), are specifically developed to achieve Nissan design and performance standards. These Original Equipment or Genuine Accessory wheels are subjected to testing to ensure they meet Nissan's standards. Nissan Original Equipment Alloy or Genuine Accessory wheels subjected to aftermarket chroming may no longer continue to meet these standards and may be seriously damaged. Therefore, Nissan most strongly discourages, and recommends that these wheels NEVER be subjected to, aftermarket chroming. See this bulletinfor further detail.
- 10192217If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut PFM Series brake lathe has been chosen as the approved tool for rotor resurfacing. - The ProCut PFM Series brake lathe can be ordered from TECH-MATE at 1-800-662-2001. - ProCut technical support or service can be obtained by calling 1-800-543-6618. NOTE: Brake rotors may need to be resurfaced during routine brake repair or for brake "judder" incidents. - Brake judder: A brake pedal pulsation and/or steering wheel shimmy when braking that occurs when there is too much thickness variation of the brake rotors (see NTB00-033). See this bulletin for further detail.
- 10192216SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into the following categories: a. Brake Noise: A squeak, squeal, clunk, or groan that occurs when the brakes are applied or released. b. Brake Judder: A vibration that can be felt in the vehicle, steering wheel or brake pedal when the brakes are applied. c. Pedal Feel: The effort needed to operate the brakes is too high or too low. SERVICE PROCEDURE 1. Verify the condition by road testing the vehicle with the customer. 2. Determine the specific brake incident based on the description in the Service Information above. 3. Follow the appropriate repair procedure(s), listed on the following pages, for your specific incident. See this bulletin for further details.
- 10192192As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed self diagnosis of major emissions systems and components. - In these instances the State may require completion of the SRT before permitting the emissions inspection to proceed. Refer to this Bulletin for further details.
- 10192145SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition which is considered normal, does not affect strut/shock absorber operation or performance, and does not require replacement. - A strut or shock absorber that should be replaced due to rod resistance/noise issues. See this bulletin for further detail.
- 10188377STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10051767Nissan: lock/unlock request button on outside handle does not respond.
- 10032506Nissan: vent control valve replacement. When replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service manuals (esm; when installing the new valve, do not add any lube to its o ring; for frontier (D40 series) only, install the protector listed in parts information. Includes 2005-09 frontier. Updated 12/8/10.
- 10031305Nissan: tire pressure monitoring system (TPMS) warning light on/flashing. No models or model years listed. Updated on 08-11-2011.
- 10030165Nissan: the 12 volt battery IS an important part of the vehicle electrical system and IS required to stay connected when the engine IS running. To prevent damage to vehicle electronic components follow the instructions/cautions. No model years listed.
- 10025522Nissan: srs precautions during service;improper maintenance, including incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all nissan models with the srs systems. Updated 2/21/14.
- 10017473Front seat belt latch plate retaining button missing.
- 10003515Front seat belt latch plate retaining button missing.
- 632164Subject regarding revised throttle position sensor (tps) adjustment procedure.
- 631971Information on nissan revised tps adjustment procdure. *Slc
- 631766Information regarding essential tool: throttle position sensor test connector. *Slc
- 629210Seat belt latch plate retaining button missing.
- 628997Some vehicles may exhibit a pop noise from the sliding door while driving.
- 628213Subject regrding sliding door pop noise while driving.
- 623162Service information regarding inner tie rod wrenches.
- 615865Experiencing an engine knocking noise when the engine IS started after an overnight cold soak, especially in cold weather.
- 613463Service information used if the door lock / unlock or the alarm sounds by themselves intermittently on an applied vehicle.
- 607626Concerns with the front seat belt latch plate stopper button missing.
- 606720Information regarding automatic transaxle output gear whine (60 - 70 mph).
- 606205Concerns with air conditioner compressor shutting off at ambient temperatures above 115 degrees f.
- 606182Key value brake pad service information.
- 605012Some vehicles may exhibit a whine noise when the vehicle IS driven between 60 and 70 mph, in third and fourth gear.
- 604996Concerns with fuel pump whining noise.
- 604301Service information on key value brake pads.
Every Nissan Quest model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.