2006 Jeep Grand Cherokee
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Jeep › Grand Cherokee › 2006
These records cover every 2006 Jeep Grand Cherokee. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2006 Jeep Grand Cherokee. Newest first.
This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand…
Risk and remedy
Risk
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the…
Risk and remedy
Risk
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Rock krawler IS recalling 44 performance suspension systems sold as aftermarket equipment for use on the vehicle listed above. these suspension systems were produced with grade 2 carriage bolts instead of the proper grade 5 carriage bolts. the improper grade 2 carriage bolts could experience a loss of clamping force for the bottom strut fork.
Risk and remedy
Risk
This condition could cause a loss of effective lift and lowering of the affected vehicle, possibly creating the driver to panic which could possibly lead to a vehicle crash.
Remedy
Rock krawler will notify owners and provide a free remedy. the safety recall began on october 15. 2008. all the affected untits have been remedied. owners may contact rock krawler at 1-518-270-9822.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
On certain sport utility vehicles, the software programmed into the ABS electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions.
Risk and remedy
Risk
This could cause a crash without warning.
Remedy
Dealers will reprogram the ABS electronic control module with new software that prevents this condition free of charge. the recall began on october 22, 2007. owners may contact chrysler at 1-800-853-1403.
On certain sport utility vehicles, the inflator connector for the driver's air bag may have been incorrectly assembled.
Risk and remedy
Risk
The air bag may not inflate properly which can increase the risk of injury in certain crash conditions.
Remedy
Dealers will repair the driver's front air bag inflator free of charge. the recall IS expected to begin the week of august 2, 2006. owners should contact daimlerchrysler at 1-800-853-1403.
Owner complaints
1,280 complaints47 involved a crash7 involved a fire41 injuries2 deaths
What owners report most
Latest complaints
- Air bags · Service brakes · Suspension
1>Air bag Recal F39 2>. Knee contract my turn off ignition switch Recal P41 3> Possibly vehicle rollover Recall N23 4> Components electrical system Recal AQ10001 5> After Market Performance Suspension system Recal 09E039000 6> ABS Electronic Control Module Recal 4GO
- Unknown or other
All of the inside door handles have broken under normal circumstances. It's almost impossible to open the doors and that to me could become a safety concern for a number of reasons. Especially if involved in an accident. Thank you for your attention to this complaint. God bless.
- Seat belts
While operating vehicle, driver's side seat belt frequently disconnects without warning.
- Electrical system › Instrument panel › Speedometer/odometer
Odometer Fraud. The contact purchased a 2006 Jeep Grand Cherokee. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 116,000, and after taking the vehicle to a certified mechanic, the Carfax report indicated that the actual mileage was 167,000. The contact had not reported the odometer fraud to another agency.
- Electrical system · Engine · Exterior lighting
Vehicle will all of a sudden shut off with out warning while driving. It has shut off while in motion going about 25miles per hour . I hurry and put it in park and restart it. It has restarted every time. Sometime the lights on the dash will flash for a moment but has only done that 2 times out of the 10 that it has shut off while driving
- Seat belts
driver's side seat belt will not buckle unless button is pushed on the buckle
- Seat belts
Something is wrong with both front driver and passenger seat belt buckle. When attempting to fasten the seat belt, something in the buckle prevents from clicking in the belt unless you press the button down. The seat belt sign stays on, raising safety concerns while operating the vehicle.
- Seat belts
seat belt on driver's side will not latch unless release button is pressed.
- Electrical system · Unknown or other
Transmission not changing gears. Transmission control module issue
- Electrical system · Engine · Unknown or other
I am experiencing so many problems with my jeep. It shift out of gear then start shutting down. Lights appear all across the dash board. At times, I have difficulty in shifting gear.The clutch slip and I get this burning smell. Then engine light comes on. It slow to move after shifting it into the…
I am experiencing so many problems with my jeep. It shift out of gear then start shutting down. Lights appear all across the dash board. At times, I have difficulty in shifting gear.The clutch slip and I get this burning smell. Then engine light comes on. It slow to move after shifting it into the forward gear. Sometimes it doesn't move when I shift it into the forward gear. Then when it does, it start bucking and kicking while driving. It slows down even when you press the gas pedal. Lastly, I have major problem with my a/c. It runs cool for a second and then completely shut off.
- Unknown or other
I bought at an auction thinking it was a decent condition
- Air bags · Seat belts
On this vehicle both front eat seatbelt receivers are faulty. This was not caused by an accident or excessive wear of the seatbelts. When you push the seatbelt into the receiver, it will not accept the seatbelt without first pushing down on the seatbelt button. Additionally, the vehicle does not…
On this vehicle both front eat seatbelt receivers are faulty. This was not caused by an accident or excessive wear of the seatbelts. When you push the seatbelt into the receiver, it will not accept the seatbelt without first pushing down on the seatbelt button. Additionally, the vehicle does not recognize when the seatbelts are in use and the light on the dash stays on regardless. This issue started some time ago, however, more recently (past 3 weeks) the airbag light started coming on intermittently. I took the vehicle to a shop (not a dealer) and they diagnosed the airbag light as being caused by the driver's side seatbelt retractor spring malfunction. They were unable to repair and directed me to a dealer. Upon contacting the dealer they are only offering replacement of the seatbelts faulty seatbelts as customers expense. I have contacted Dodge customer service and asked what assistance they my provide. That issues is currently open under case number 89679478.
- Electrical system
The contact owns a 2006 Jeep Grand Cherokee. The contact stated while driving at approximately 55 MPH and attempting to merge into traffic the vehicle stalled. The contact stated that several unknown warning lights illuminated; however, the vehicle coasted to a stop and all the electrical power had…
The contact owns a 2006 Jeep Grand Cherokee. The contact stated while driving at approximately 55 MPH and attempting to merge into traffic the vehicle stalled. The contact stated that several unknown warning lights illuminated; however, the vehicle coasted to a stop and all the electrical power had failed. The contact turned the ignition to the off position and waited before restarting the vehicle and the vehicle returned to normal functionality. The contact stated that the electrical failure and the vehicle stalling were intermittent at first, but have since become a recurring failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the braking system needed to be replaced. The vehicle was repaired; however, the stalling and electrical failure reoccurred. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V438000 (Electrical System). The failure mileage was approximately 175,000.
- Unknown or other
The door handle cups are disintegrating and handles are breaking off. I seen this is a safety issue many owners of jeeps like mine having same issues I haven't owned it a year, it's in pristine condition otherwise with only 91,000 original miles You can't get out from the inside in case of…
The door handle cups are disintegrating and handles are breaking off. I seen this is a safety issue many owners of jeeps like mine having same issues I haven't owned it a year, it's in pristine condition otherwise with only 91,000 original miles You can't get out from the inside in case of emergency bith front & one rear are currently broken & u can't even locate replacement door panels as discontinued there is a repair that is available but why should I pay for what obviously is manufacturer issue I will file a class action lawsuit along with others if not addressed & Jeep/Chrysler can give me way more than the car is even worth. I don't want my grandchildren & I to die because we can't get out in fire or flood. I bought the car used at 84,000 miles and would never have thought to check door handle cups until a pieces of one fell out Probably why he sold it to me with such low miles
- Electrical system · Engine · Steering
The ignition I believe lost connection with the key fob. Multiple times while driving the vehicle will randomly just die. An when trying to start sometimes it does nothing unless you push key in a certain way.
- Electrical system · Service brakes · Unknown or other
While driving on the highway the entire car suddenly shut off, on three separate occasions. All the lights lit up on the dashboard then the car would not accelerate. I turned it off when I reached the shoulder, waited about a minute then turned the car on again. I am grateful my daughter and I are…
While driving on the highway the entire car suddenly shut off, on three separate occasions. All the lights lit up on the dashboard then the car would not accelerate. I turned it off when I reached the shoulder, waited about a minute then turned the car on again. I am grateful my daughter and I are still alive. I've had it in the repair shop for a month. They replaced the brake system and dealt with grounding issues but, they cannot figure out why it keeps happening. This is a very serious issue and I see that others have complained about it. Yes, the car is old and has over 175,000 miles on it but I see that this is a common problem so it should be addressed.
- Electrical system · Exterior lighting
driving down the road my head lights with flicker on and off and its making the lights inside the jeep go on and off as well reported this awhile ago as well due to the face that tis is not safe while going down the road sometimes it will shut off on its own while driving and then it will come right back in like nothing happened
- Electrical system · Engine
If vehicle sits for more then 8 hours you can drive it - but once the vehicle has been turned off Vehicle will not turn on for more then 5-10 seconds and will just turn off. Sometimes it says invalid key when it’s the primary key and not spares. Acts as if it has kill switch. Problem keeps happening constantly
- Air bags · Power train · Service brakes
Car is currently parked: I own a 2006 Jeep Grand Cherokee Larado which Jeep claims has no recalls yet there (3) all of which are happening to my vehicle. NHTSA 07V434000, 13V175000 and 14V438000. My car is very well maintained I have reached out to Jeep and claim my truck was not recalled yet my…
Car is currently parked: I own a 2006 Jeep Grand Cherokee Larado which Jeep claims has no recalls yet there (3) all of which are happening to my vehicle. NHTSA 07V434000, 13V175000 and 14V438000. My car is very well maintained I have reached out to Jeep and claim my truck was not recalled yet my TRUCK is listed as having (6) recalls all of which are issues the truck is currently having. I have computer codes to prove it. I understand my truck have 150,000 miles and is 16 almost 17 years old however it was bought as an investment that Jeep seems to selectively correct issues only when they are threatened to be sued. This is totally ridiculous. There are multiple complaints from other owners. These things should have been recalled years ago. My vehicle has never been modified and we should not have to be responsible for recalls that are selectively being fixed when there are over 6000 complaints. Thank you
- Seat belts
Driver seatbelt unlatches after secured. Several times i’ve had to make a sudden stop and my seatbelt comes undone . The airbag light did come on prior. I’m not sure if that warning light relates to seatbelt as well. I plan on taking it into the dealership to find out why the light is on. This is…
Driver seatbelt unlatches after secured. Several times i’ve had to make a sudden stop and my seatbelt comes undone . The airbag light did come on prior. I’m not sure if that warning light relates to seatbelt as well. I plan on taking it into the dealership to find out why the light is on. This is my sons car however I borrowed it for a few days and discovered this. He is a new driver And still learning about different mechanical issues that arise.
- Seat belts
I can't buckle either front seatbelts. I bought the Jeep new and it started this recently. It started with the front passenger belt first.
- Electrical system · Exterior lighting · Fuel/propulsion system
The vehicle's gauges will turn off while driving randomly. The speedometer, odometer, tachometer, fuel gauge will all zero out for unspecified amounts of time. Sometimes 10 seconds, other times until the vehicle is started back up. This occurs when the vehicle is in motion. So, is very dangerous.…
The vehicle's gauges will turn off while driving randomly. The speedometer, odometer, tachometer, fuel gauge will all zero out for unspecified amounts of time. Sometimes 10 seconds, other times until the vehicle is started back up. This occurs when the vehicle is in motion. So, is very dangerous. Sometimes it causes the car to completely shut off and come back on. While shut off, the car sounds like it is struggling to continue its forward progress. This happens occasionally. Once the car corrects itself, the check engine light appears. After starting the car 2-3 times, the misfire corrects itself. I did a previous report related to the air bag light is on, but not sure if it is related with the same electrical problem.
- Electrical system · Unknown or other
There wasn’t an accident while driving my vehicle (thank god). My key stopped working for my ignition. I had an ignition recall on my vehicle (as to what the dealership told me). My vehicle has now been with the dealership since around Christmas maybe even a little bit before that. They did my…
There wasn’t an accident while driving my vehicle (thank god). My key stopped working for my ignition. I had an ignition recall on my vehicle (as to what the dealership told me). My vehicle has now been with the dealership since around Christmas maybe even a little bit before that. They did my ignition recall as to what was wrong with the vehicle. So they say.. it was towed in because it would not turn over.. they gave me a new key and put in a “new ignition” and still would not turn over. The dealership said my key would not flash over with the computer? Also, stating I needed a new skim module. Which they stated that Chrysler discontinued that part. I was not offered a rental.. which is fine I guess.. I’m a single mother of two kids. It has now been about four months about. I have never had in my life had the problems that I do now. My job is about to fire me, completely. The problems that I have had getting my children to and from school and doctor appointments, etc. I’m really at a loss for words. My vehicle had no problem starting before the ignition - key - issue. I really don’t know what else to do.
- Visibility › Sun/moon roof assembly
The contact owns a 2006 Jeep Grand Cherokee. The contact stated while driving at 65 MPH, there was a sound of wind coming from the sunroof. The contact stated that as he opened the sunshade guard, the sunroof glass detached from the vehicle. The contact veered to the side of the road to check that…
The contact owns a 2006 Jeep Grand Cherokee. The contact stated while driving at 65 MPH, there was a sound of wind coming from the sunroof. The contact stated that as he opened the sunshade guard, the sunroof glass detached from the vehicle. The contact veered to the side of the road to check that the sunroof glass had not struck any other vehicles. The contact then continued to drive the vehicle. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 149,000.
- Air bags
Air bags light in the dashboard is on without any accident. Air bags are original, seems to be in good conditions or without any physical damage on the exterior. Call my attention the recalls for the Air bags light in others Jeep Grand Cherokee from others years.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Air Bag Non-deployment
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an…
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
- Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary…
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010205Plate - Planetary
- 10229256KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10229213Customer Satisfaction Notification P73 Reprogram Final Drive Control Module The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the ?Service 4WD? light to come on and an inability to switch 4WD mode when trying to shift out of the current selected mode. The Final Drive Control Module (FDCM) must be reprogrammed with new software.
- 10229181Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10223710Exterior Mirror The latest version of these exterior mirrors have had their glass removed to be serviced separatly. To install, connect the electrial connector (if equipped) and snap the glass onto the mirror housing.
- 10223602Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10223599Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
- 10221686KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10221097Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
- 10220843NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission
- 10220471Mechanical rocker arm, intake, 1.7 ratio.
- 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10220099Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10220097Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 102177274WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 102177054WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 10216001New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 10191460Valve Body. These may cause over drive cycling.
- 10191442Mechanical rocker arm, intake, 1.7 ratio.
- 10190590NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission
- 10188696New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 10175743Disinfectant Solution Recommended for COVID-19
- 10175735Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
- 10169249Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10169247Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10169245Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 10148868Customer Satisfaction Notification P73 Reprogram Final Drive Control Module: The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the service 4WD light to come on and an inability to switch 4WD mode when trying to shift out of the current selected mode. The Final Drive Control Module (FDCM) must be reprogrammed with new software.
- 10148577P41 Interim Repair Procedure Brazil ONLY Some Jeep Commander and Jeep Grand Cherokee vehicles may experience an unintended change in ignition switch position while driving which may result in loss of engine power, power steering, and braking assist increasing the risk of a crash and disabling one or more of the vehicle?s safety features including the frontal airbags. Chrysler intends to repair the vehicle free of charge (parts and labor). However, the part required to provide a permanent remedy for this condition is currently not available.
- 101412424WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated.Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 101412204WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 10139704UConnect Hands Free Module Fails To Respond Due To Module Lock Up This bulletin involves replacing the Hands Free Module (HFM) if required. The HFM fails to operate causing the UConnect Hands Free Communications system to not respond when system activation is attempted by the customer. Further diagnosis may reveal that when the wiTECH scan tool is used to read Diagnostic Trouble Codes (DTCs) the tool indicates that the module is not responding. Other modules on the bus may display loss of communication with the HFM. If the Hands Free Communication system is unresponsive then the HFM may require electronic reset.To perform a electronic reset, turn off the vehicle and pull the Ignition Off Drain (IOD) fuse. Wait a few minutes before reinstalling the IOD fuse and checking if the HFM is communicating. If the HFM still will not communicate, then normal No Response diagnostic should be performed. If the HFM is working properly, the module should be replaced to prevent this condition from happening again.
- 10136982Part Description: Actuator Motor
- 10136874New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 1012900882212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
- 10121927NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
- 10069323Summary to be provided on a future date.
- 10069322Summary to be provided on a future date.
- 10058278Fiat chrysler: tsb has an owner notification letter. Select document search button below. When shifting out of current selected mode, final drive control module (fdcm) software causes service 4WD light to illuminate and switching out of 4WD fails and needs reprogramming. Model 2005-2010 jeep grand cherokee, jeep commander.
- 10030347Chrysler/jeep: flash: esp system may prematurely activate momentarily when negotiating a curve or mil illumination due to diagnostic trouble code p0340, p0344 or p0116. This involves selectively erasing and reprogramming the powertrain control module (pcm) with new software. Updated 5/24/10.
- 10024083Positive crankcase ventilation (pcv) system freezes in extreme cold ambient temperatures -- involves installing revised pcv system components.
Every Jeep Grand Cherokee model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.