2011 Jeep Grand Cherokee
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Jeep › Grand Cherokee › 2011
These records cover every 2011 Jeep Grand Cherokee. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2011 Jeep Grand Cherokee. Newest first.
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Risk and remedy
Risk
A vehicle stall increases the risk of a crash.
Remedy
Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
Risk and remedy
Risk
If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also…
Risk and remedy
Risk
The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Remedy
Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Chrysler Group LLC (Chrysler) is recalling certain model year 2011 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, to July 20, 2011, and equipped with either a 3.6L or 5.7L engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without…
Risk and remedy
Risk
A vehicle stall increases the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM, free of charge. The recall began December 19, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P54. Note: This recall has been superseded by recall 19V813.
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
Risk and remedy
Risk
If the vanity lamp wiring shorts, there is an increased risk of fire.
Remedy
Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
Risk and remedy
Risk
The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Owner complaints
1,641 complaints53 involved a crash61 involved a fire47 injuries2 deaths
What owners report most
Latest complaints
- Engine · Service brakes
I took my vehicle to Vaden Jeep on Chatham Parkway in Savannah, GA for the recall on the brake booster and was told there was a waiting liat to get parts to repair my vehicle. It have been over a year and I still have not received anythi g regarding my brake booster. Also, the recall for the TPIM for my make/model does not seem to be done. My vehicle still acts though it was never done.
- Electrical system
The contact owns a 2011 Jeep Grand Cherokee. The contact stated that while driving at a slow speed, the A/C unit started blowing warm air, with the battery, ABS, and malfunction indicator warning lights illuminated. The vehicle stalled, and the contact to pulled over to the shoulder. Upon…
The contact owns a 2011 Jeep Grand Cherokee. The contact stated that while driving at a slow speed, the A/C unit started blowing warm air, with the battery, ABS, and malfunction indicator warning lights illuminated. The vehicle stalled, and the contact to pulled over to the shoulder. Upon inspection, there was extreme heat and a burning odor coming from the engine compartment. A mobile mechanic jumpstarted the vehicle and the vehicle was driven to the residence. The battery was replaced, but the failure recurred immediately after the next start-up. The contact associated the failure with NHTSA Campaign Number: 17V435000 (Electrical System); however, the dealer confirmed that the VIN was not included in the recall. The failure mileage was approximately 250,000.
- Engine · Fuel/propulsion system
The car shut off and I can’t get it back on it does not jump I tried replacing the alternator but that’s not it
- Air bags
The contact owned a 2011 Jeep Grand Cherokee. The contact stated that while driving 40-45 MPH, the vehicle rear-ended another Jeep vehicle stopped at the red light; however, the air bags failed to deploy. The contact mentioned that there was no brake pedal depressed in attempts to stop, therefore…
The contact owned a 2011 Jeep Grand Cherokee. The contact stated that while driving 40-45 MPH, the vehicle rear-ended another Jeep vehicle stopped at the red light; however, the air bags failed to deploy. The contact mentioned that there was no brake pedal depressed in attempts to stop, therefore the vehicle was going at full speed. The windshield washer fluid warning light was flashing, and there was smoke coming from the driver's side front end of the vehicle after the crash. The contact stated that the radiator was caved in due to the impact. The contact did not sustain major injuries. The vehicle was towed and totaled by the insurance company. A police report was filed. Neither the dealer nor the manufacturer was contacted. The failure mileage was approximately 187,000. The VIN and the License plate numbers were not available.
- Engine · Fuel/propulsion system
Car has died while driving 4 times in the last 3 years. Complete loss of power WHILE driving. Lost of power steering, loss of brakes while driving. Chrystler is saying recall was resolved by previous owner but it is still happening. EXTREMELY dangerous. I have paid out of pocket to replace the TIPM (over $3000) and I was not told about the fuel pump relay issue associated and connected with this recall.
- Fuel/propulsion system
I had a recall for my 2011 Jeep grand Cherokee to repair a faulty fuel pump relay causing hard starting now it’s starting to intermittently do the same thing sometimes starts right up then sometimes will crank a long time before starting. This is what it was doing before they did the recall now it’s doing it again
- Electrical system · Engine
On February 3, Tuesday drove home from work. The battery light came on. I Drove to AutoZone and they placed it on Diagnostic reader. The diagnostic reader said that the battery had no charge. They told me I need a new battery. I replaced the battery. The next morning, I placed the jeep into auto…
On February 3, Tuesday drove home from work. The battery light came on. I Drove to AutoZone and they placed it on Diagnostic reader. The diagnostic reader said that the battery had no charge. They told me I need a new battery. I replaced the battery. The next morning, I placed the jeep into auto start. So the Jeep can warm up. When I went outside, there was smoke coming from underneath the hood of the Jeep. I quickly turn off the Jeep and pop the hood. My husband open the hood and can see smoke coming from the alternator. He turned around to turn off his vehicle that was running. I started to video recording the incident and stopped it right away when I started to see flames coming out of the alternator. My husband and I quick action was to grab snow that was next to the Jeep to throw it onto the alternator to put the fire out. It took multiple piles of snow that the husband went and grabbed the fire extinguisher and sprayed the alternator to extinguish the fire. Once the fire was extinguished. We kept an eye out to make sure everything was good. We left the hood up to cool things down. We called morgan Towing to have the Jeep towed to their location to look at the situation. Morgan Towing picked the jeep up on February 4 Wednesday. They replaced the serpentine belt and the alternator. They called us to let us know the Jeep was done. Picked up the Jeep today, February 5 Thursday. I Drove it literally down the street and I can smell strong odor of smoke along with the battery light came back on. I turned back around and brought it back to Morgan Towing. I called my auto insurance and waiting to hear back from them. I am going to call the Dodge Jeep dealership and see what they have to say if if there’s was any recall on the Jeep. Upon my research so far, I didn’t see no recall but again I’m gonna call the dealership.
- Electrical system · Forward collision avoidance › Adaptive cruise control · Suspension
My right side suspension has a hard time coming up and I can hear it then it eventually get to right level and my car is freaking out have every light come on and the windshield wipers but it doesn't always do it but I have videos. The codes I get say malfunctional control u1403 and other ones
- Vehicle speed control
The vehicle accelerated on its own unable to control or stop the vehicle
- Electrical system
Started Jeep and after driver info cycled through on dash, the battery warning light came on. Battery had been replaced by local Jeep dealer within last 12 months. Contacted dealer, Keller Motors, while sitting in vehicle and made arrangements to drop off. Drove 3 miles to town with light still…
Started Jeep and after driver info cycled through on dash, the battery warning light came on. Battery had been replaced by local Jeep dealer within last 12 months. Contacted dealer, Keller Motors, while sitting in vehicle and made arrangements to drop off. Drove 3 miles to town with light still on. Then seat belt warning light came on and vehicle electrical system suffered complete shut down and would not restart. Got out and detected a smoke smell. Vehicle would not restart. Had vehicle towed to local Jeep dealer and reported issues to service manager. They will look at Jeep next week. Have there been similar incidents reported? Thanks, [XXX] [XXX] [XXX] 2801 PCR [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system · Fuel system, gasoline
The contact owns a 2011 Jeep Grand Cherokee. The contact received a notification of NHTSA Campaign Number: 19V813000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that shortly after starting the engine, the vehicle experienced a loss of…
The contact owns a 2011 Jeep Grand Cherokee. The contact received a notification of NHTSA Campaign Number: 19V813000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that shortly after starting the engine, the vehicle experienced a loss of motive power. The check engine warning light illuminated. The vehicle was towed to the local dealer, where it was repaired under NHTSA Campaign: 17V572000; however, parts were not available for NHTSA Campaign: 19V813000(Electrical System). In addition, the local dealer advised the contact that the vehicle was in need of a fuel pump replacement. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 141,000.
- Electrical system · Engine
My check light is blinking and then it stop says I have a random misfire and I done replaced coils spark plugs fuel injectors and I done paid ppl to look at it they none really know what's wrong and I have from my crankshaft sensor all the way up to my cylinder 2 rewired bc my crank wouldn't let my car start got that fixed and I stil have the issue and it just has the misfire and dont know where its coming from..
- Engine
My Jeep 2011 Jeep Grand Cherokee was repaired under Recall P54 (NHTSA 14V-530) on October 20, 2016, which was supposed to fix a fuel-pump relay defect that could cause engine stalling. Despite the recall repair, stalling continued and worsened, forcing me to pay $573.56 for an independent repair on…
My Jeep 2011 Jeep Grand Cherokee was repaired under Recall P54 (NHTSA 14V-530) on October 20, 2016, which was supposed to fix a fuel-pump relay defect that could cause engine stalling. Despite the recall repair, stalling continued and worsened, forcing me to pay $573.56 for an independent repair on July 16, 2024 to restore safe operation. Jeep later issued Recall V62 (NHTSA 19V-813) in 2019, acknowledging that the earlier P54 recall fix was defective and could fail due to silicon contamination. I did not receive notice of V62 until late summer 2025, long after paying for repairs. Jeep denied my reimbursement request, citing lack of prior contact and the fact that repairs were done by an independent shop. This is unfair and contrary to federal recall reimbursement policy, since the defect was safety-related, the original recall fix failed, and Jeep admitted that V62 was issued to correct P54’s failure. I request that NHTSA review this case and ensure Stellantis/Jeep complies with recall reimbursement obligations under 49 CFR §573.13.
- Power train
Transfer case chain making terrible noise under the drivers side
- Fuel/propulsion system
To whom it may concern My 2011 jeep grand Cherokee has a very strong gasoline smell to the point I get dizzy when I’m driving it and a instant migraine Even if the car is parked in my drive way overnight the next morning you can smell gasoline from the outside too Please help me Thank you for your time
- Electrical system · Engine
The contact owns a 2011 Jeep Grand Cherokee. The contact stated that the vehicle occasionally stalled while at a complete stop. The contact stated that the vehicle was able to restart after several attempts, approximately 15 minutes. The vehicle was taken to an independent mechanic, where the…
The contact owns a 2011 Jeep Grand Cherokee. The contact stated that the vehicle occasionally stalled while at a complete stop. The contact stated that the vehicle was able to restart after several attempts, approximately 15 minutes. The vehicle was taken to an independent mechanic, where the failure could not be duplicated; however, the contact was informed that the vehicle could be experiencing a fuel pump relay failure. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V813000 (Electrical System); however, the VIN was not included in the recall. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 158,660.
- Electrical system · Fuel/propulsion system
Vehicle is stuttering and stalling out due to the computer being broke
- Electrical system
The contact owns a 2011 Jeep Grand Cherokee. The contact stated while driving at an undisclosed speed, the low battery warning light illuminated and there was heavy smoke coming from under the hood. In addition, there was a burning odor on the interior of the vehicle. The vehicle was towed to the…
The contact owns a 2011 Jeep Grand Cherokee. The contact stated while driving at an undisclosed speed, the low battery warning light illuminated and there was heavy smoke coming from under the hood. In addition, there was a burning odor on the interior of the vehicle. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced NHTSA Campaign Number: 14V634000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall. The failure mileage was approximately 89,900.
- Electrical system · Engine
Alternator caught fire
- Engine
The engine oil filter housing cooler (part number is: 5184294AE) are made of dissimilar materials (plastic and aluminum) and with normal hot oil temperatures the materials expand and contract at different rates causing failure of the part and leaks. The leak causes loss of engine oil and engine…
The engine oil filter housing cooler (part number is: 5184294AE) are made of dissimilar materials (plastic and aluminum) and with normal hot oil temperatures the materials expand and contract at different rates causing failure of the part and leaks. The leak causes loss of engine oil and engine coolant that can sudden engine damage while driving putting the driver and passengers at risk. This seems to affect not only this 2011 Jeep Grand Cherokee vehicle with a 3.6 Liter engine, but almost all 3.6 Liter engines in other Chrysler, Jeep, Dodge, and Ram vehicles.
- Engine
There is a Customer satisfaction report P01 for timing chain and timing chain guides for 2009-2012 vehicles equipped with the 5.7L Hemi. My vehicle is now undrivable because of this issue and caused piston and valve damage. Because of my VIN not being listed for this recall I am now facing a $9500 engine replacement due to this issue.
- Electrical system
The contact owns a 2011 Jeep Grand Cherokee. The contact had received notification of NHTSA Campaign Number: 14V530000 (ELECTRICAL SYSTEM); and the vehicle was taken to a local dealer where the recall repair was performed; however, several days after the recall repair, the vehicle was hesitating…
The contact owns a 2011 Jeep Grand Cherokee. The contact had received notification of NHTSA Campaign Number: 14V530000 (ELECTRICAL SYSTEM); and the vehicle was taken to a local dealer where the recall repair was performed; however, several days after the recall repair, the vehicle was hesitating while being started. The contact stated that the Battery Charging and Electronic Throttle Control warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 153,000.
- Electrical system
Rear Camera has been intermittent since I got the car new and dark image and not crystal clear . The lens is clean and it works intermittently.. the dealership said it would cost $1000.00 to replace the camera.. since there are recalls currently on other jeeps can you help add my vehicle in the…
Rear Camera has been intermittent since I got the car new and dark image and not crystal clear . The lens is clean and it works intermittently.. the dealership said it would cost $1000.00 to replace the camera.. since there are recalls currently on other jeeps can you help add my vehicle in the mix.. I just spent over 5000 dollars to get my exhaust system fixed and they didn't even give me a loaner car . Bad cus service and this should be fixed.. a safety issue to me.. just like the recall..
- Electrical system
The contact owns a 2011 Jeep Grand Cherokee. The contact stated while driving at an undisclosed speed, there was smoke was coming from under the hood. The contact pulled into a parking lot to inspect the vehicle and became aware that the alternator was burning red hot. The battery warning light…
The contact owns a 2011 Jeep Grand Cherokee. The contact stated while driving at an undisclosed speed, there was smoke was coming from under the hood. The contact pulled into a parking lot to inspect the vehicle and became aware that the alternator was burning red hot. The battery warning light illuminated. The vehicle was inspected by a local independent mechanic who was nearby during the failure, and it was determined that the alternator had overheated. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 17V435000 (Electrical System); however, the VIN was not included. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.
- Electrical system · Engine · Unknown or other
Since I bought it at the dealership the car hesitates to start, I took it several times and they couldn't find the fault, they said it could be a problem with the battery so I changed it and it kept doing the same thing. thing, they told me what the tank was. of gasoline I took it to a Nhtsa office…
Since I bought it at the dealership the car hesitates to start, I took it several times and they couldn't find the fault, they said it could be a problem with the battery so I changed it and it kept doing the same thing. thing, they told me what the tank was. of gasoline I took it to a Nhtsa office and they told me that they would change the part, over time I had the same problem again but now a year has passed and the car no longer starts, from the beginning they have not helped me solve the problem problem. problem problem that comes from the factory.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
- Active Head Rest Inadvertent Deployment
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When…
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Post 14V-391 Headliner Fires
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY)…
In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1
- Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007…
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
- Headliner Fires
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January…
On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con
- Headliner Fires
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while…
The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011512HEADREST Incoming Vehicles with Deployed Active Head Rest (AHR) should have a through enquiry. If there is no Broken Pieces or Electrical failure, Direction to follow the RESET Procedure in service Library to RESET the AHR
- 11010205Plate - Planetary
- 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10247906ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10247905ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10242717Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
- 10240958Headlamp without ballast,if ballast needed order part number : 68086783a$
- 10234379ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10234378ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10229962This bulletin involves road testing and if necessary replacing the intermediate shaft
- 10229945MIL Illumination: P0300, P0302, P0304 or P0306 (X56 Warranty Extension)
- 10229899MIL Illumination: P0300, P0302, P0304 or P0306 (X56 Warranty Extension) This bulletin involves checking for excessive cylinder leakage and replacing the cylinder head if necessary. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that any the following Diagnostic Trouble Codes have been set: P0300- Multiple Cylinder Misfire P0302- Cylinder 2 Misfire P0304- Cylinder 4 Misfire P0306- Cylinder 6 Misfire
- 10229871Dielectric Grease This product is no longer approved for use on ignition coil and spark plug boots. Current plug boot material(silicone) is not compatible with this grease and can cause deterioration over time.
- 10229869New Safety Recall Advanced Communication ? P14040214 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2011 through 2014 model year (WD) Dodge Durango and (WK) Jeep Grand Cherokee vehicles. Some Jeep Grand Cherokee and Dodge Durango vehicles may have a brake booster that could prematurely corrode. If perforation of the brake booster shell (due to corrosion) occurs, the brake booster may ingest water during vehicle operation during wet weather conditions. A brake booster that has experienced water ingestion may have the brake function compromised if the water inside the brake booster freezes. The driver may be required to apply additional application force to apply the brakes during sub-freezing driving conditions. An unexpected additional brake pedal application force requirement could slow the driver?s brake application reaction time and cause a crash without warning. Chrysler will conduct a voluntary safety recall on all involved vehicles to inspect the brake booster for corrosion. Brake boosters found with excessive corrosion will be replaced. All boosters will be equipped with a shield to protect the brake booster crimp joints from water exposure. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 10229825RHW RHP Radio Software Enhancements
- 10229572Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10229031Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary.
- 10228020Customer Satisfaction Notification V51 Reprogram Powertrain Control Module
- 10227983If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
- 10225424Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10225287Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10224870Steering Column If vehicle comes in for steering column replacement, verify column installed. Go to Info Column in Star Parts and open the flow chart to determine which column is installed. If column is Daimler, verify that a replacement Daimler column is in stock and use for replacement. If no Daimler column is in stock, replacement must use Presta column (which require a number of other components to be replaced). For more information and details on PN's, see W-Series Flowchart in Star Parts. Contact parts specifying for assistance regarding correct part numbers, for technical assistance contact Star.
- 10224859Seat Shields For vehicles built prior to 5/2/2011:~ Replace old shield (1UN79TRMAA) with new shield (1XN97TRMAA) and bracket (68100737AA).~ Replace old shield (1UP58TRMAA) with new shield (1XN08TRMAA) and bracket (68100737AA).~ Replace old shield (1UQ14TRMAA) with new shield (1XN96TRMAA) and bracket (68100737AA).~ The new bracket (68100737AA) is only needed if the vehicle doesn't already have it (check PN on phyical part)
- 10224652Chirping Or Squeaking Coming From The Second Row Headrest This bulletin involves applying lubricant to the headrest mechanism and seat back panel crossmember. Customers may describe a chirping or squeaking coming from the rear second row seat headrest(s) while driving.
- 10224074Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on the following:The AHR is deployed on one or both front seats and will not reset.
- 10224061Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)
- 10223978Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension This bulletin involves replacing upper leather IP covers that have suffered delamination issues. Customers may comment on the following:The upper leather IP cover is delaminating or separating.
- 10223599Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
- 10221869Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension This bulletin involves replacing upper leather IP covers that have suffered delamination issues. Customers may comment on the following:The upper leather IP cover is delaminating or separating.
- 10221813No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- 10221274Air Suspension System Diagnosis
- 10221154No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message
- 10221097Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
- 10221067MIL Illumination: P0300, P0302, P0304 or P0306 (X56 Warranty Extension) This bulletin involves checking for excessive cylinder leakage and replacing the cylinder head if necessary. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that any the following Diagnostic Trouble Codes have been set: P0300- Multiple Cylinder Misfire P0302- Cylinder 2 Misfire P0304- Cylinder 4 Misfire P0306- Cylinder 6 Misfire
- 10220923Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.
- 10220687Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary.
- 10220487Recall Advanced Communication.
- 10220423Squeal Noise From Front Of Vehicle When Braking This bulletin involves verifying the front vehicle noise and if necessary replace the front brake pads. Squeal noise from front of vehicle when braking.
- 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
Every Jeep Grand Cherokee model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.