2007 Jeep Grand Cherokee
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Jeep › Grand Cherokee › 2007
These records cover every 2007 Jeep Grand Cherokee. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2007 Jeep Grand Cherokee. Newest first.
This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand…
Risk and remedy
Risk
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the…
Risk and remedy
Risk
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Rock krawler IS recalling 44 performance suspension systems sold as aftermarket equipment for use on the vehicle listed above. these suspension systems were produced with grade 2 carriage bolts instead of the proper grade 5 carriage bolts. the improper grade 2 carriage bolts could experience a loss of clamping force for the bottom strut fork.
Risk and remedy
Risk
This condition could cause a loss of effective lift and lowering of the affected vehicle, possibly creating the driver to panic which could possibly lead to a vehicle crash.
Remedy
Rock krawler will notify owners and provide a free remedy. the safety recall began on october 15. 2008. all the affected untits have been remedied. owners may contact rock krawler at 1-518-270-9822.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
On certain sport utility vehicles, the software programmed into the ABS electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions.
Risk and remedy
Risk
This could cause a crash without warning.
Remedy
Dealers will reprogram the ABS electronic control module with new software that prevents this condition free of charge. the recall began on october 22, 2007. owners may contact chrysler at 1-800-853-1403.
On certain sport utility vehicles, front brake calipers in a certain lot may have been manufactured from gray iron instead of ductile iron as designed and could fracture without warning.
Risk and remedy
Risk
This would increase the vehicle's stopping distance and could cause a crash.
Remedy
Dealers will inspect the front brake calipers to see if they fall into this lot and, if so, will replace them free of charge. The recall began on october 22, 2007. owners may contact daimlerchrysler at 1-800-853-1403.
On certain vehicles, the antilock brake system (ABS) control module software may cause the rear brakes to lock up during certain braking conditions.
Risk and remedy
Risk
This could result in a loss of vehicle control and cause a crash without warning.
Remedy
Dealers will reprogram the ABS electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403.
Owner complaints
1,109 complaints31 involved a crash11 involved a fire21 injuries
What owners report most
Latest complaints
- Engine
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while driving at approximately 40 MPH and exiting an expressway, the vehicle stalled while the brake pedal was depressed to decelerate. The contact shifted into Neutral (N), and the engine was restarted to resume driving. Less…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while driving at approximately 40 MPH and exiting an expressway, the vehicle stalled while the brake pedal was depressed to decelerate. The contact shifted into Neutral (N), and the engine was restarted to resume driving. Less than 5 miles later, the failure recurred while making a right turn. The vehicle was taken to an independent mechanic, who diagnosed a failed throttle body and replaced the component. Following the repair, the failure persisted and increased in frequency, occurring while decelerating or coming to a complete stop. The dealer was contacted and confirmed that the VIN was not included in a recall. The failure mileage was 124,981.
- Electrical system
The contact owns a 2007 Jeep Grand Cherokee. The contact stated after the ignition switch was replaced under NHTSA Campaign Number: 14V438000 (Electrical System), the vehicle started making an abnormally loud sound at startup. The vehicle was taken to Auto Zone; however, no diagnostic trouble code…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated after the ignition switch was replaced under NHTSA Campaign Number: 14V438000 (Electrical System), the vehicle started making an abnormally loud sound at startup. The vehicle was taken to Auto Zone; however, no diagnostic trouble code was retrieved. The vehicle not diagnosed or repaired. The dealer and the manufacturer were notified of the failure. The failure mileage was approximately 192,000.
- Engine · Exterior lighting · Service brakes
I was driving and wrecked into a sign because I was unable to stop and the vehicle caught on fire under the hood.
- Electrical system · Engine · Exterior lighting
I was pulling into the gas station to get some gas. I'm used to use a 2-ft drive so what I could not lift my left foot to put pressure on the brake I used my right foot. It slipped off the brake and after the accelerator and I hit a small Pole stopping me from going into the gas station front door. Just could have been raised up to a work accident I had a couple weeks prior.
- Unknown or other
I have a warning light telling me to check my gas cap. I check out and nothing seems to be wrong. But I do go through a lot of gas. I don't know if there needs to be a new gas cap put on or if it's part of the fuel system
- Electrical system · Exterior lighting
When I'm driving down the road my car won't shut off. I have to pull over to the side of the road turn my key completely off and take it out put it back in and start it. It takes a couple of times to get it started as I have to move the key back and forth and then it will start. I did a check…
When I'm driving down the road my car won't shut off. I have to pull over to the side of the road turn my key completely off and take it out put it back in and start it. It takes a couple of times to get it started as I have to move the key back and forth and then it will start. I did a check engine light check. And it is saying something about a Anti-Theft ignition problem. My headlights stay on all the time and blink when it is shut off.
- Electrical system
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V438000 (Electrical System) by the previous owner; however, the recall repair failed to prevent the failure from occurring. The contact stated that while driving…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V438000 (Electrical System) by the previous owner; however, the recall repair failed to prevent the failure from occurring. The contact stated that while driving at various speeds, the vehicle momentarily lost automotive power and occasionally shut off while idling. The local dealer informed the contact that the parts needed to repair the vehicle were not available. Additionally, the contact attempted to temporarily repair the vehicle with an after-market part; however, the failure reoccurred. The vehicle was not repaired due to parts not being available. The vehicle was towed to an independent mechanic where the crankshaft sensor was replaced; however, the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000.
- Electrical system
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that the vehicle intermittently failed to start up after several attempts. The contact stated that there were several unknown warning lights illuminated. The vehicle was taken to the dealer on several occasions, and the contact was…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that the vehicle intermittently failed to start up after several attempts. The contact stated that there were several unknown warning lights illuminated. The vehicle was taken to the dealer on several occasions, and the contact was informed that the failure could not be duplicated. The vehicle was not diagnosed or repaired and remained with the dealer. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V438000 (Electrical System). The contact related the failure to the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 113,000.
- Service brakes, hydraulic
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while driving at undisclosed speeds, the contact became aware that the front brakes were separating. The contact stated that the air bag warning light was illuminated. The local dealer was contacted and advised that the vehicle…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while driving at undisclosed speeds, the contact became aware that the front brakes were separating. The contact stated that the air bag warning light was illuminated. The local dealer was contacted and advised that the vehicle was not included in a recall. The contact related the failure to NHTSA Campaign Number: 16V168000 (Service Brakes, Hydraulic). The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 100,000.
- Tires › Sidewall
The contact's granddaughter owns a 2007 Jeep Grand Cherokee equipped with Cooper Tires, Tire Line: Discoverer EnduraMax, Tire Size: P245/65/R17, DOT Number: [XXX] . The contact stated while the driver was driving at 70 MPH, the rear passenger's tire had a blowout. The driver was able to pull to the…
The contact's granddaughter owns a 2007 Jeep Grand Cherokee equipped with Cooper Tires, Tire Line: Discoverer EnduraMax, Tire Size: P245/65/R17, DOT Number: [XXX] . The contact stated while the driver was driving at 70 MPH, the rear passenger's tire had a blowout. The driver was able to pull to the side of the road. The vehicle was towed to the residence, where the tire was inspected, and the contact became aware that the tire had blown out at the sidewall. The manufacturer was notified of the failure, and the defective tire was shipped to the manufacturer for inspection. The manufacturer later informed the contact that the tire failure had been caused by a pinhole that gradually deflated the tire until the tire had the blowout; however, the contact stated that the TPMS did not indicate a loss of tire air pressure prior to the blowout, and that the failure had occurred abruptly. The manufacturer offered to partially reimburse the cost of the tire. The contact purchased a new tire from the dealer and replaced the tire himself. The vehicle failure mileage was approximately 189,000, and the tire failure mileage was approximately 4,000. The VIN was not available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system
Intermittent starting issues for 5+ years, multiple repairs with no resolution
- Structure › Body › Door · Unknown or other
2007 Jeep Grand Cherokee inside door handles cannot be open any of the doors from the inside you have to open it from the outside because the plastic of the inside door handles are made of cheap plastic and Chrysler knows about it ever since 2005 to 2011 and never had a recall what concerns me with…
2007 Jeep Grand Cherokee inside door handles cannot be open any of the doors from the inside you have to open it from the outside because the plastic of the inside door handles are made of cheap plastic and Chrysler knows about it ever since 2005 to 2011 and never had a recall what concerns me with people have small children that you can't get out of the vehicle in a time of the emergency and it really concerns me if the vehicle ever caught on fire or flooded or underwater you can't get out and it's the death trap
- Air bags · Electrical system
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while his daughter was driving approximately 50 MPH, the instrument panel lost functionality and became inoperable. The contact stated that radio was also inoperable. The contact stated that after parking the vehicle overnight, it…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that while his daughter was driving approximately 50 MPH, the instrument panel lost functionality and became inoperable. The contact stated that radio was also inoperable. The contact stated that after parking the vehicle overnight, it was discovered that the passenger’s side air bag had deployed. The vehicle had not been taken to the dealer, but the dealer was contacted by phone. The contact was informed that the failure was a known issue and that an unknown computer or software needed to be replaced. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.
- Electrical system
Vehicle will not start randomly. The battery has been checked, the relays and fuses have been checked, the starter has been replaced, and the fuel pump and fuel filer have been checked. The issue continues sporadically and leaves the driver stranded. There is an known issue with the ignition switch…
Vehicle will not start randomly. The battery has been checked, the relays and fuses have been checked, the starter has been replaced, and the fuel pump and fuel filer have been checked. The issue continues sporadically and leaves the driver stranded. There is an known issue with the ignition switch on these Jeeps as my 2008 Jeep Cherokee was recalled for this reason but there is no recall for the 2007 for this same reason.
- Electrical system · Engine · Fuel/propulsion system
2007 Jeep Grand Cherokee 4.7L when driving on roadway the rpm go up down and then the Jeep shot off and then put the vehicle in neutral and turn the key start and the vehicle up and when driving again and the start again and took the vehicle to Jeep dealer and there don’t find anything wrong.
- Electrical system
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that upon pushing the START button to start the vehicle, the vehicle failed to start. The dealer was notified of the failure and informed the contact that she would be responsible for the towing expense and for the repair of the…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated that upon pushing the START button to start the vehicle, the vehicle failed to start. The dealer was notified of the failure and informed the contact that she would be responsible for the towing expense and for the repair of the vehicle as the vehicle was out of warranty. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V438000 (Electrical System) which she associated with the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 142,000.
- Engine
The contact owns a 2007 Jeep Grand Cherokee. The contact stated while at a stop sign and attempting to accelerate, the vehicle stalled. There were no warning lights illuminated. The battery was previously replaced. The vehicle was towed to an independent mechanic and the contact was made aware of a…
The contact owns a 2007 Jeep Grand Cherokee. The contact stated while at a stop sign and attempting to accelerate, the vehicle stalled. There were no warning lights illuminated. The battery was previously replaced. The vehicle was towed to an independent mechanic and the contact was made aware of a faulty ignition switch. The vehicle was towed to the local dealer who informed the contact that the wires were loose. The mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the dealer however, no further assistance was provided. The approximate failure mileage was 170,000.
- Electrical system · Unknown or other
When I am driving, all of the lights on my dash come on. Seatbelt, check engine, brakes, low tire pressure etc. The stay on for a couple of seconds. Then EVERYTHING turns off for about half a second. Gas gauge, rpm, speedometer all go down to zero, which is how it is when I turn the jeep off. While…
When I am driving, all of the lights on my dash come on. Seatbelt, check engine, brakes, low tire pressure etc. The stay on for a couple of seconds. Then EVERYTHING turns off for about half a second. Gas gauge, rpm, speedometer all go down to zero, which is how it is when I turn the jeep off. While I'm still driving and going 45 mph! Then every thing turns back on. It happened about 5 months ago once. Then today it happened about 15 times as I drove home from my mother's house, which is about 7-9 miles from my house.
- Exterior lighting · Fuel/propulsion system
went in for inspection and found out my vehicle has a small gas leak and turn signal and stomp lamps not working brake lights not working and emission system -obdii system faults
- Electrical system · Engine
While driving the jeep on the interstate at 65 mph lost all power was able to get it to the side of the road and after a minute it restarted it has done it numerous times sometimes sitting at a traffic light sometimes driving 25 mph through town there IS no warning no dash signs of anything wrong…
While driving the jeep on the interstate at 65 mph lost all power was able to get it to the side of the road and after a minute it restarted it has done it numerous times sometimes sitting at a traffic light sometimes driving 25 mph through town there IS no warning no dash signs of anything wrong vehicle just shut off lose all power terrifying took it to a jeep dealer couldn't duplicate the problem also the radio plays and the dash display does not light up my power windows will go up and down by themselves and end up halfway. I only been able to drive the car short distances because of the fear of death lose breaking and steering. Have seen other complaints with the same issues on the internet why IS this vehicle allowed to be on the road
- Electrical system · Engine · Exterior lighting
I would be driving down the road and my jeep will shut off all by itself and then turn back on all while driving down the expressway doing 75mph my steering wheel and lights and breaks would all lock up then the jeep would just pop back on and then the rpm's would be really high so I would have to…
I would be driving down the road and my jeep will shut off all by itself and then turn back on all while driving down the expressway doing 75mph my steering wheel and lights and breaks would all lock up then the jeep would just pop back on and then the rpm's would be really high so I would have to hit the breaks to slow way down so my jeep wouldn't blow up on me . I've taken it to like 5 mechanics and they can not figure what's wrong with it . Then also I can get in my jeep and start it and my radio and backup camera won't work and some of my gages wouldn't register when I start it ups don't start going down the road so I will have to pull over shut my jeep off and pull the key out and open the door to make sure everything IS off then put the key can in and restart it and sometimes it will work and sometimes I will have to do it a few times to get it to work .
- Electrical system
Engine turns off while driving.it has happened several times before , intermittently. February 3RD, 2021, january 17TH, 2021, and several times before.
- Electrical system
The 4-wheel drive transfer case can direct engine power to the rear wheels only, all four wheels, or in its neutral position, non at all. These vehicles are being recalled because the transfer case can shift into its neutral position without warning. If this were to occur, engine power would not…
The 4-wheel drive transfer case can direct engine power to the rear wheels only, all four wheels, or in its neutral position, non at all. These vehicles are being recalled because the transfer case can shift into its neutral position without warning. If this were to occur, engine power would not reach any of the drive wheels and the vehicle could not move under its own power. Dealers will reprogram the final drive controller which governs the transfer case to correct this concern.
- Electrical system · Engine
Jeep IS having electrical issues. It will randomly go into limp mode at start, but turning it off and restarting it fixes that issue. It's done this three times in the 2 years we have had it. I am now having an electrical issue where something IS causing a draw on the battery while the vehicle IS…
Jeep IS having electrical issues. It will randomly go into limp mode at start, but turning it off and restarting it fixes that issue. It's done this three times in the 2 years we have had it. I am now having an electrical issue where something IS causing a draw on the battery while the vehicle IS turned off. I have had to replace the alternator, starter, and now the battery.it IS causing the battery to swell, and the jeep IS having to be jumped to start multiple times a week. The battery was put on a deep charge, and it had to be jumped the next day. Also the air conditioning back lighting goes off and on when you turn the knobs or adjust the fan speed while both driving and stationary. This has been going on for roughly a month.
- Electrical system · Engine · Fuel/propulsion system
The jeep has electrical stuff happening sporadically and does not start but with power but after 3 to 6 attempts starts right up. I turn key all power and bells go off and it makes a humming noise and 1 click noise dash says ' transmission over temp' the jeep IS cold so not over temperature. I've…
The jeep has electrical stuff happening sporadically and does not start but with power but after 3 to 6 attempts starts right up. I turn key all power and bells go off and it makes a humming noise and 1 click noise dash says ' transmission over temp' the jeep IS cold so not over temperature. I've seen a lot of post about recall and also about ignition switch or module. I've only owned for 2 years and dealer said car had no recalls when I purchased. this happens stationary and also after driving about 20 minutes to destination and when I went to leave it took several times before starting. This has been going on for last 3 days but few messages randomly popped in information center few times before this had at dealer on computer no codes said it was okay
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Air Bag Non-deployment
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an…
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
- Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary…
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010205Plate - Planetary
- 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10229213Customer Satisfaction Notification P73 Reprogram Final Drive Control Module The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the ?Service 4WD? light to come on and an inability to switch 4WD mode when trying to shift out of the current selected mode. The Final Drive Control Module (FDCM) must be reprogrammed with new software.
- 10229181Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10223710Exterior Mirror The latest version of these exterior mirrors have had their glass removed to be serviced separatly. To install, connect the electrial connector (if equipped) and snap the glass onto the mirror housing.
- 10223602Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10223599Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
- 10221097Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
- 10220843NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission
- 10220471Mechanical rocker arm, intake, 1.7 ratio.
- 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10220099Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10220097Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 10220015DAMPER, Transfer Case Reman Transfer Case will arrive equipped with the Transfer Case Damper. Please return core with original damper intact.
- 102177274WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 102177054WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 10216395Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
- 10216001New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 10191460Valve Body. These may cause over drive cycling.
- 10191442Mechanical rocker arm, intake, 1.7 ratio.
- 10190590NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission
- 10188696New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 10175743Disinfectant Solution Recommended for COVID-19
- 10175735Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
- 10169249Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10169247Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10169245Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 10169163DAMPER, Transfer Case Reman Transfer Case will arrive equipped with the Transfer Case Damper. Please return core with original damper intact.
- 10148868Customer Satisfaction Notification P73 Reprogram Final Drive Control Module: The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the service 4WD light to come on and an inability to switch 4WD mode when trying to shift out of the current selected mode. The Final Drive Control Module (FDCM) must be reprogrammed with new software.
- 10148577P41 Interim Repair Procedure Brazil ONLY Some Jeep Commander and Jeep Grand Cherokee vehicles may experience an unintended change in ignition switch position while driving which may result in loss of engine power, power steering, and braking assist increasing the risk of a crash and disabling one or more of the vehicle?s safety features including the frontal airbags. Chrysler intends to repair the vehicle free of charge (parts and labor). However, the part required to provide a permanent remedy for this condition is currently not available.
- 101412424WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated.Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 101412204WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indicate that the ?Service 4WD? indicator in the instrument cluster is illuminated. They may also indicate that the transfer case will not shift from 4WD High, 4WD Low, and/or Neutral once the lamp is illuminated. Further investigation identifies that a Diagnostic Trouble Code C140F is stored or active in the Final Drive Control Modules (FDCM) Memory
- 10140065Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
- 10139978Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
- 10138987Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
- 10136982Part Description: Actuator Motor
- 10136874New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Quadra-Trac II four wheel drive system. Some of the above vehicles may experience a transfer case actuator encoder electrical failure that results in unintentional transfer case shifting into or through the neutral position. NOTE: These vehicles are equipped with a NV245 transfer case that is part of the automatic four wheel drive system. The transfer case shifts into and out of four wheel drive modes and ranges automatically or based on driver inputs. Chrysler will conduct a voluntary safety recall on all affected vehicles to reprogram the Final Drive Controller Module (FDCM) with new software. The four wheel drive system will then be function tested. Vehicles found with an inoperative transfer case actuator will also have the actuator replaced. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
- 1012900882212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
- 10128948Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
Every Jeep Grand Cherokee model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.