2012 Ford Expedition

Recalls

3 recalls name the 2012 Ford Expedition. Newest first.

• Power train › Automatic transmission

  Apr 27, 2016NHTSA 16V248000153,581 vehicles

  Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.

  Risk and remedy

  Risk

  An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.

  Remedy

  Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.

  Full recall details →

• Exterior lighting › Back up lights

  May 3, 2012NHTSA 12V19000010,500 vehicles

  Ford IS recalling certain model year 2011-2012 ford F-150, 2012 expedition and lincoln navigator, and 2012-2013 mustang vehicles, for failing to comply with the requirements of federal motor vehicle safety standard nos. 102, "transmission shift lever sequence, starter interlock, and transmission braking effect" and 108 “lamps, reflective devices and…

  Risk and remedy

  Risk

  If this condition exists, the transmission may not go into reverse or when the driver pushes the shift lever in the reverse “r” position and the vehicle’s transmission does go in reverse, the “r” may not illuminate on the dashboard of the F-150, expedition, or navigator models and/or the backup lamp on the rear of the F-150, expedition, navigator, or mustang vehicles may not illuminate. these conditions increase the risk of a crash or a pedestrian being struck due to the vehicle’s not signaling it IS in reverse.

  Remedy

  Ford will notify owners, and dealers will inspect and replace the trs as necessary, free of charge. the safety recall began on june 11, 2012. owners may contact ford motor company customer relationship center at 1-866-436-7332.

  Full recall details →

• Seats › Mid/rear assembly

  Feb 2, 2012NHTSA 12V034000569 vehicles

  Ford IS recalling certain model year 2012 expedition and lincoln navigator vehicles, manufactured from november 19, 2011, through december 2, 2011, for failing to comply with the requirements of federal motor vehicle safety standard no. 202, "head restraints." these vehicles may have inadequate welds on the head restraint support brackets for the second…

  Risk and remedy

  Risk

  In the event of a crash, the seat head restraint may not provide the required strength, increasing the risk of injury.

  Remedy

  Ford will notify owners, and dealers will replace the head restraints as necessary, free of charge. the safety recall began on february 21, 2012. owners may contact ford motor company customer relationship center at 1-866-436-7332.

  Full recall details →

Owner complaints

What owners report most

1. Power train64
2. Electrical system20
3. Vehicle speed control18
4. Structure15
5. Engine12
6. Unknown or other9
7. Service brakes6
8. Fuel/propulsion system4
9. Suspension3
10. Air bags3

Latest complaints

• Aug 12, 2026KS
  Fuel/propulsion system · Vehicle speed control

  vehicle shifting erratically and shows fuel mileage low and loss of speedometer

• Aug 12, 2026KS
  Fuel/propulsion system · Vehicle speed control

  vehicle shifting erratically and shows fuel mileage low and loss of speedometer

• Apr 7, 2026MA166,000 mi
  Engine · Power train
  The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was…

  The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the manufacturer, but there was no response. The failure mileage was approximately 166,000.

• Feb 24, 2026CA
  Power train

  While exiting the freeway at approximately 45 to 50 mph, the transmission downshifted to 1st gear locking up the tires.

• Nov 17, 2025KS
  Vehicle speed control
  The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer…

  The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again

• Oct 22, 2025OK
  Power train
  Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but…

  Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had to swerve to miss us. The check engine light was on advance track light same codes pulled. The dealership said it’s not in the recall even though it was built in Jefferson co Kentucky 9/2011. I don’t understand why this vehicle wasn’t recalled . I have to continue to drive it’s my only vehicle. I’m so scared for my life.

• Sep 10, 2025NJ78,000 mi
  Back over prevention
  The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the…

  The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.

• Aug 29, 2025IN
  Power train · Vehicle speed control
  I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle…

  I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the recall and I shouldn't have had to pay anything .. them replacing the lead frame did nothing the car is still not drive able and is extremely unsafe its my only vehicle and I am a single mother of 2 kids .

• Aug 10, 2025GA
  Service brakes · Unknown or other

  ABS CPU control system. Error Code B1342-EC. Antilock braking system electronic control unit defect.

• Jul 26, 2025WI
  Electrical system · Power train · Vehicle speed control
  July 2025 my 2012 ford expedition threw a p0742 code for a stuck torque converter clutch. The vehicle had just under 150K miles and started to jerk in and out of gear and the wrench light illuminated so i, thankfully was going approximately 45 mph when it happened and was able to pull the vehicle…

  July 2025 my 2012 ford expedition threw a p0742 code for a stuck torque converter clutch. The vehicle had just under 150K miles and started to jerk in and out of gear and the wrench light illuminated so i, thankfully was going approximately 45 mph when it happened and was able to pull the vehicle over as it was in limp mode. When I cleared the dtc code the problem went away temporarily but eventually locked back up again within a mile from my home. Unfortunately, ford dealerships will not stand behind the customer service number that they have listed for a replacement of the transmission lead frame. I provided the local dealership with all of the necessary information as well as an independent diagnosis by a transmission specialist. Looks like I'll just have to wait for the day that it causes a massive accident by downshifting into 1ST gear at 65mph. Terrible customer service and I can only hope this doesn't cost someone their life.

• Jul 25, 2025WI
  Electrical system · Engine · Power train

  Campaign 19N01 Description Transmission molded leadframe extended coverage Next Steps Contact your dealer for next steps. Did this and was told that the vehicle was not covered due to it being after 10 years and barely over 150,000 miles. I am experiencing transmission issues where the torque converter clutch is now stuck on and the lead frame is more than likely the cause. Thanks FORD, NEVER AGAIN.

• Jul 25, 2025WI
  Electrical system · Power train · Vehicle speed control
  I just purchased (2 months ago) a 2012 ford expedition el 5.4l v8 from a private party. I wish I would have done more research as I am already experiencing transmission issues that I believe are directly related to the vehicles lead frame recall. It threw a p0742 code on me torque converter clutch…

  I just purchased (2 months ago) a 2012 ford expedition el 5.4l v8 from a private party. I wish I would have done more research as I am already experiencing transmission issues that I believe are directly related to the vehicles lead frame recall. It threw a p0742 code on me torque converter clutch circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this unexpected shifting into 1ST gear at highway speeds IS, it IS equally as dangerous to be getting out of your vehicle in moving traffic due to ford's terrible design on this vehicles power train/transmission system. I have scheduled an appointment with the local ford dealer and al certain I'll get the runaround/blame game for this one. 150K miles and as I said, I have owned it for 2 months and have already had transmission issues, brake issues, belt tensioner pulley literally fell off.. And from what I read, what's next??? The cam phasers?? That's if the transmission issue IS even fixed and it becomes safely drive able again. Come on ford, get your act together, you're better than this!

• May 21, 2025NC
  Power train
  Transmission failed to engage after startup, and while driving will slip out like its in neutral without warning. There was a series of messages that rolled over and over as the vehicle slowed. When we first took it to have it serviced for this problem June of 2024, they optioned to flush, change…

  Transmission failed to engage after startup, and while driving will slip out like its in neutral without warning. There was a series of messages that rolled over and over as the vehicle slowed. When we first took it to have it serviced for this problem June of 2024, they optioned to flush, change the filter, and put in new transmission fluid. They could not reproduce the problem. That seemed to take care of it until May 17, 2025 when it started slipping again. Again, the service center cannot reproduce the problem. The sudden slowdown, puts us in a risk for an accident with other vehicles. The vehicle is available for inspection if needed.

• Jul 12, 2024GA
  Power train

  While driving my vehicle, the transmission down shift on its on and the vehicle antilock brakes hit and suddenly stops on its on.

• Jul 2, 2024GA203,000 mi
  Power train
  The contact owns a 2012 Ford Expedition. The contact stated while driving 45 MPH, the vehicle started jerking and downshifted unintendedly. The contact stated there were two unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the output…

  The contact owns a 2012 Ford Expedition. The contact stated while driving 45 MPH, the vehicle started jerking and downshifted unintendedly. The contact stated there were two unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the output speed sensor had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V248000 (Power Train); however, the VIN was not included. The dealer was contacted and informed the contact there would be no assistance because the vehicle was out of warranty. The manufacturer was not notified of the failure. The failure mileage was approximately 203,000.

• May 24, 2024OK
  Power train
  On [XXX] @ [XXX]. I was traveling [XXX] in Logan Co., OK in my 2012 Ford Expedition EL (purchased used Jan. 2020) at an approximate speed of 45 mph when the vehicle downshifted into 1st gear causing a rapid deceleration wherein the vehicle behind me had to take evasive action to avoid rear ending…

  On [XXX] @ [XXX]. I was traveling [XXX] in Logan Co., OK in my 2012 Ford Expedition EL (purchased used Jan. 2020) at an approximate speed of 45 mph when the vehicle downshifted into 1st gear causing a rapid deceleration wherein the vehicle behind me had to take evasive action to avoid rear ending me. The engine rpms climbed significantly while the speedometer stopped working and the vehicle never shifted into any higher gears for the next five blocks wherein I was able to pull my vehicle into a safe place. Again, the vehicle continued only in 1st gear! After turning the vehicle off and letting it sit for a few minutes, it appeared everything had reset and I slowly drove it straight to my mechanics shop. (However, shop was closed until after Memorial Day, so I again drove it slowly back home). Total trip was approximate 12 miles. Issue took place approximate 5 miles from when I left my residence. Ironically, I had visited my mechanic the day before inquiring about an issue wherein the vehicle would beep and a "wrench symbol" would display on the instrument panel and the speedometer and instrument display would stop working. I advised this was the 2nd time that issue occurred within the past few days, however, once the vehicle was turned off and restarted, all seem to be okay. In responding to my inquiry, my mechanic seemed to think it was an instrument cluster issue. That if it persisted, return to have it checked out. Never during any of these two (2) prior occurrences did the vehicle downshift as it did on the [XXX] of May. As an attorney, I began researching potential causes and came across the NHTSA's previous investigation(s) into this issue. However, I am dumbfounded that as serious as this issue is, NO recall has been made. As to me, it is my understanding that Ford's Customer Service Program has even expired regarding fixing this life threatening issue. I am lucky that there was not a semi-truck behind me or it would have been serious. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

• Oct 19, 2023TNCrash
  Power train · Structure › Body · Vehicle speed control
  The transmission jumps in and out of gear, the engine revs on its on. I was on the highway the first time and I going between 60 and 65 mph and it sounded like the whole bottom of the truck was just ripped out, the truck went from drive to either park or first gear it locked up the back tires and…

  The transmission jumps in and out of gear, the engine revs on its on. I was on the highway the first time and I going between 60 and 65 mph and it sounded like the whole bottom of the truck was just ripped out, the truck went from drive to either park or first gear it locked up the back tires and there was a truck behind me he tried to miss me but he hit the back passenger side of the truck. He was very very upset he threatening and cussing me because he thought I just slammed on my brakes for no reason. I explained to him what was happening and calmed down think God. It could have killed him or me or even several other people. When it locked up the tires then it jumped back in drive and tried tot take off, I threw it in neutral and cut the key off. That scared the sh.. out of me!! I have talked to other people that have around the same year model truck as mine and some of them are having the same issues with it jumping in and out of gear not wanting to shift gears revving up on its own and no engine light comes on I've tried to get a code scanner scan it no codes come up on the truck Ford needs to fix this truck they had a recall on certain models that were manufactured at different plants or something like that I heard but they won't fix my truck they said it's not under recall this truck is going to kill somebody it's the only truck I have and I have to go to work I'm just asking if you can please do something about this before people get killed in or I get killed I'm going to try to get a video of what it does I'm just asking if you can please do something about this Ford knows what the problem is I read stuff on it and they need to fix these trucks before it kills people they know what the problem is if I have a bad wreck and I live to it or this truck causing somebody to lose their life it's going to be a multi multi multi million dollar lawsuit because they refuse to fix the truck I'm just asking you if you can please do something about this thank you

• Sep 6, 2023TXFire
  Electrical system · Engine · Unknown or other
  I was driving regularly down the road when I noticed the smell of electrical fire. Smoke started coming from the undercarriage of the truck. I pulled into a gas station, and the engine died, and I got out to look at what's causing the smoke. I observed what looked to be engine or transmission…

  I was driving regularly down the road when I noticed the smell of electrical fire. Smoke started coming from the undercarriage of the truck. I pulled into a gas station, and the engine died, and I got out to look at what's causing the smoke. I observed what looked to be engine or transmission oil on fire dripping from the undercarriage, so I moved a safe distance from the vehicle, and within about 30 seconds, the entire vehicle was engulfed in flames. The fire department came, and extinguished the fire. The vehicle is 100% casualty, along with everything inside of it.

• Jul 3, 2023MO100,112 mi
  Power train
  The contact owns a 2012 Ford Expedition. The contact stated that upon his wife depressing the accelerator pedal, the RPM raised abruptly however, the vehicle failed to respond. The contact stated that the vehicle lost motive power and seemed as if the transmission was in neutral(N). After…

  The contact owns a 2012 Ford Expedition. The contact stated that upon his wife depressing the accelerator pedal, the RPM raised abruptly however, the vehicle failed to respond. The contact stated that the vehicle lost motive power and seemed as if the transmission was in neutral(N). After restarting the vehicle and shifting to drive(D), the vehicle returned to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that a failure had occurred with the transmission molded lead frame. The vehicle was not repaired due to parts not being available. Upon investigation, the contact related the failure to Customer Satisfaction Program: 19N01-Supplement #1 (Power Train) However, the vehicle was out of warranty. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 100,112.

• Feb 14, 2023KS
  Back over prevention › Sensing system › Camera · Structure › Body
  Metal corrosion on the back liftgate is allowing water to leech into the electrical connections to the back camera, causing it to intermittently not work leading to complete failure eventually. The service techs at the ford dealership have described this common problem with this year model…

  Metal corrosion on the back liftgate is allowing water to leech into the electrical connections to the back camera, causing it to intermittently not work leading to complete failure eventually. The service techs at the ford dealership have described this common problem with this year model expeditions and is due to a chemical problem either with the metal or factory paint or both. Corrosion is not due to rust. We bought the car new in late 2011.

• Dec 5, 2022NJ59,959 mi
  Power train
  The contact owns a 2012 Ford Expedition. The contact stated while driving approximately 45 MPH, the vehicle suddenly failed to accelerate while depressing the accelerator pedal. The vehicle independently decelerated and nearly caused the vehicle to be rear ended by a tractor trailer. The contact…

  The contact owns a 2012 Ford Expedition. The contact stated while driving approximately 45 MPH, the vehicle suddenly failed to accelerate while depressing the accelerator pedal. The vehicle independently decelerated and nearly caused the vehicle to be rear ended by a tractor trailer. The contact indicated that the vehicle was driven home with the transmission stuck in 3rd gear. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 59,959.

• Sep 21, 2022TX
  Power train
  Uncommanded downshift to first gear in 6R80 transmission. While driving at approximately 30mph, transmission downshifted into 1st gear. Problem repeated itself several times. No "codes" or warning lights. I put the transmission in "3" and drove slowly back home. This is the same issue that has…

  Uncommanded downshift to first gear in 6R80 transmission. While driving at approximately 30mph, transmission downshifted into 1st gear. Problem repeated itself several times. No "codes" or warning lights. I put the transmission in "3" and drove slowly back home. This is the same issue that has occurred in F-150's. The problem was intermittent at first. Had this occurred at highway speeds it may have resulted in a rear end "lock-up", loss of control and possible accident. Took the vehicle to the repair shop where they were initially unable to get a "code". Later, I was able to repeat the problem and got warning lights and codes showing failure of the transmission output speed sensor which is located on the molded lead frame. This is the same failure as on the F-150. The molded lead frame was not available as single piece so it was necessary to replace the entire valve body unit.

• Jun 6, 2022NJ
  Electrical system · Unknown or other · Vehicle speed control

  My vehicle suddenly shifted downward, my gas pedal had no effect, my speedometer stopped working and my fuel and tire sensor lights came on. This happened multiple times on my drive this morning and would have caused an accident if I was being tailgated.

• May 2, 2022AR150,000 mi
  Engine
  The contact owns a 2012 Ford Expedition. The contact stated while driving at approximately 30 MPH, the vehicle independently slowed to approximately 2 MPH. The contact observed that the check engine warning light illuminated. Additionally, the speedometer went blank. The contact stated that when…

  The contact owns a 2012 Ford Expedition. The contact stated while driving at approximately 30 MPH, the vehicle independently slowed to approximately 2 MPH. The contact observed that the check engine warning light illuminated. Additionally, the speedometer went blank. The contact stated that when she depressed the accelerator, the vehicle would jerk forward. The contact pulled off of the road and turned off the vehicle. The contact stated that when she restarted the vehicle the vehicle failed to respond when shifted into drive with the accelerator pedal depressed. The contact stated that she drove the vehicle to her residence. The vehicle was diagnosed by an independent mechanic who could not duplicate the failure. The vehicle was not repaired. The contact stated that the failure recurred intermittently. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

• Mar 29, 2022WA
  Service brakes
  My wife backed my vehicle out of the garage and began her drive to work. She stopped a few times at stop light through town before she got to the freeway. Driving on the highway she notice/got a message on the dash that stated Low Brake Fluid. She wasn't sure what that meant as the brakes were…

  My wife backed my vehicle out of the garage and began her drive to work. She stopped a few times at stop light through town before she got to the freeway. Driving on the highway she notice/got a message on the dash that stated Low Brake Fluid. She wasn't sure what that meant as the brakes were working fine. On her drive to work she has 2 stop lights that are on the highway. Coming up to the first stop light she was unable to stop as the brake pedal went all the way to the floor. Her inability to stop caused to to run the red light at around 40 mph. I am a mechanic of 20 years. I went to her work to inspect the vehicle. There were no leaks or broken hoses, the master cylinder was empty except for the front of the reservoir that had maybe an 1/8" of fluid in it. Upon doing some internet research I found that 2013 - 2014 F-150 had the exact same problem with the master cylinder leaking into the brake booster causing the loss of the service brake system to function properly. More research found that the master cylinder in question is the same part number used on all f150 and expeditions from 2010 -2014. The recall number is 16s24. I called Ford customer service and was told that my vehicle had no open recalls. I explained to the agent that I understood recalls are VIN specific but my vehicle has the same master cylinder (based on part number) as the ones failing in the F150 and it has failed in the exact same way (brake fluid leaking, or being sucked into the brake booster) as described in the recall for this issue. This is a serious issue as the brakes worked as designed one minute and there was no brakes the next when needed. The only warning was a low brake fluid light/message. My wife could have been killed or killed someone else had there been another vehicle entering the intersection. There easily could have been a crash/fire/injury or fatality. How many failures/deaths do there need to be before a recall is issued and Ford does the right thing.

Defect investigations

NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.

• Unexpected Transmission Downshift

  RQ17010Opened Dec 25, 2017Closed Oct 22, 2019Recall 19V075000
  The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged…

  The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11008948While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
• 11005305This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
• 10254138All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
• 10235153For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
• 10214754Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
• 10205031Touchscreen navigation system - arabic language - blank screen
• 1020498749 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
• 1020498649 CFR Part 579.5 Monthly Communications - January 2016
• 10201087This program extends the warranty coverage of the automatic transmission molded leadframe to 10 years of service or 150,000 miles from the warranty start date of the vehicle, whichever occurs first. This is a one-time repair program.
• 10201086This program extends the warranty coverage of the automatic transmission molded leadframe to 10 years of service or 150,000 miles from the warranty start date of the vehicle, whichever occurs first. This is a one-time repair program.
• 10183767Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.
• 10183669Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped with A 6R80 Transmission Transmission Molded Leadframe Extended Coverage In some of the affected vehicles, an output shaft speed (OSS) sensor failure may result in an illuminated malfunction indicator light (MIL) and/or wrench light in the instrument cluster with diagnostic trouble codes (DTCs) P0720, P0722, P0731 and/or P1500 stored in the powertrain control module (PCM).
• 10181917Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply line.
• 10177863This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
• 10164508Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found, inspect the area of the glass that is covered by the cowl and/or molding. The portion of glass that is covered by the cowl or molding will not be affected by the acid. Hydrofluoric acid damage is not a defect in material or workmanship and is not a warrantable condition.
• 10164497For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable clamp and clean the cable end as necessary to preserve wire length. Some rework may be necessary for some vehicle environments. Bend the new positive battery cable clamp as needed and crimp it to the existing battery cable. Make sure to use heat shrink tubing over the battery cable to battery cable clamp connection. Obtain the heat shrink tube locally.
• 10163573Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Use pigtail harness service part numbers 3U2Z-14S411-ZEA or CU2Z-14S411-FA, as both parts are interchangeable. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures.
• 10162411Customer Satisfaction Program 19N01: Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Transmission Molded Leadframe Extended Coverage
• 10160931On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.
• 10159510Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Transmission Molded Leadframe Extended Coverage
• 10156877Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures. Refer to Wiring Diagram, Cells 54/55 to obtain the service pigtail connector part number.
• 10156863Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
• 10156539Certain 2012 - 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Sudden Transmission Downshift - Powertrain Control Module Reprogramming
• 10155565Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. This may be due to a poor electrical connection at the blower motor speed control. If the blower motor speed control is determined to be the causal part, replacement of the electrical connector pigtail harness (14S411) to the blower motor speed control is also recommended to avoid repeat repairs. Refer to Wiring Diagram, Cell 5 for recommended splicing procedures. Refer to Wiring Diagram, Cells 54/55 to obtain the service pigtail connector part number.
• 10155551Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
• 10153969Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
• 10143079Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
• 10140323The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.
• 10138524The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.
• 10137113Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems. If you suspect a system has been modified, the following resources can be used to verify original equipment: Monroney Label (Window Sticker), Professional Technician Society (PTS) OASIS tab  select SYNC or HVBOM. For Genuine Ford accessories use: PTS Workshop Tab  select Dealer Installed Accessory or Accessory Installation.
• 101365972010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10127405Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the on-screen instructions to complete the procedure. This procedure will transfer the existing Key ID information between the modules without the need of having 2 programmed PATS keys present. There is no need to program keys when the PCM is going to be replaced. Additional information can be found in the Workshop Manual (WSM), Section 419-01. Missing or lost keys are not warrantable.
• 10109079Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
• 10109070The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
• 100994632009-2017 vehicles equipped with a 6R80, 6r100, 6r140 automatic transmission have an updated main control valve body overhaul procedure. Refer to workshop manual (wsm), section 307-01 for main control valve body (7a100) overhaul procedures. Not all valve bodies require replacement. Inspect the valve body bores, springs and valves as directed during diagnosis and repair. Refer to general service bulletin (gsb) g0000093 automatic transmission main control inspection for a video clip to aid in the diagnosis of these repairs.
• 10095154To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye IS available. Workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. The new white fluorescent dye provides a distinct white glow to identify engine oil leaks. The new white fluorescent dye requires a pure uv diagnostic inspection lamp. The white-colored fluorescent dye and pure uv lamp are now in the rotunda catalog. Dye and lamp part numbers. Gasoline only dye: 1 ounce bottle 164-tp-33200601. Diesel only dye: 8 ounce bottle: 164-tp-3320-0008. Pure uv diagnostic inspection lamp 164-tp8695 or 164-r3748.
• 10095102Some 2011-2016 expedition and navigator vehicles may exhibit a rattle noise from the roof opening panel shield while driving over bumps. Follow the service procedure steps to correct the condition.
• 10091155Certain 2011-2012 model year F-150 and 2012 model year expedition, navigator and mustang vehicles equipped with a 6R80 transmission - molded leadframe extended coverage
• 10091151Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service IS required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps illuminated in the instrument cluster. Rerun the vhr with the engine on and vehicle in park, and ensure the park brake IS disengaged. If the sync vhr IS still reporting a concern to the customers sync owners account, refer to the appropriate workshop manual section for diagnosis by dtc or symptom. Starting in 2015 not all sync equipped vehicles support vhr, refer to the owners manual for vhr operation.
• 10090681Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service IS required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps illuminated in the instrument cluster. Rerun the vhr with the engine on and vehicle in park, and ensure the park brake IS disengaged. If the sync vhr IS still reporting a concern to the customers sync owners account, refer to the appropriate workshop manual section for diagnosis by dtc or symptom. Starting in 2015 not all sync equipped vehicles support vhr, refer to the owners manual for vhr operation.

Every Ford Expedition model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.